Professional Documents
Culture Documents
GP6000 Terminal Wire Connection Definition
GP6000 Terminal Wire Connection Definition
A
1 2 2 1 2 1
B
2 1
GSM
GPS
2 1
2 1
Power input
A1 GND/black A2 power supply input/red A4 cut off fuel pump /white A5 speaker/yellow
C4 C3
SIM card
C1 GND/connect to ground
COM2
B8 MIC+ B7 MICB6 SPK+ B5 SPKB4 TXD B3 RXD B2 +5V B1 GND 4 RS232-TXD 3 RS232-RXD
A10 air-condition detecting(high level trigger)/purple A11 engine detecting(high level trigger)/brown A12 brake detecting(high level trigger)/purple white
2 +5V 1 GND
power output
COM1
Signal detection
A13 fuel level signal detecting 1/orange white A14 pulse signal detecting(low
level trigger)/brown white
A15 door detecting(low level trigger)/gray white A16 panic button(low level trigger)/yellow black
Remark
1High level detecting trigger:6.2V-40V is valid ; Low level detecting trigger : below 2.8V is valid. 2The bearing current of the control port (low level control) is 0.35A . The max instant bearing current is 0.5A . 3GP6000 rated voltage:12V-24V,normal working voltage:10V-33V(if over this voltage , unit will use backup battery or shutdown), the max bearing input voltage is:60V,working current is about: 0.1A . 4The communication level signal of COM1 and COM2 is standard RS-232 level , and PORT B is TTL level (0-5V) . 5Mileage pulse signal detecting trigger : lower 4V is valid . for example: the speed ratio value normally is on the mileage meter . for example:650:1 means 650 circles in 1 kilometer . Normally, using this value multiply 8 when you input the value in GP6000 client software : such as 650*8=5200 . 6Green indicator 1:Blink 0.2 second then stop for 1 second means NO GSM signal .Blink 0.2 second then stop 5 seconds means GSM signal is OK. Blink quickly means GSM signal is good and already connected to server network. 7Red indicator 2: Blink 0.2 second then stop for 1 second means GPS antenna is not connected or GPS module is not working; Constant blink means GPS module works normally ; Dark means GPS module has problem . 8Fuel level signal detecting range: 0-5V . This function need special fuel level sensor to match.