• When programming for first time select delete program to clear all programming accept all and ok • The logical sequence for initial programming is to program the panel parameters first, then to program the individual points through autoprogramming and/or point programming. Programming nfs 3030 • Section no 3 program • Two levels • Program and alter status • Program level require master password, point function system function and passwords • Alter status do detector sensitivity time/date etc • When an annucaitor active the program screen gone and event count display • By pressing alter program it will require passwork either go for program or alter status Panel programming • Node Number: • If you have standalone panel than by default it is 000 • Range 1-240 • Default is style 4, 4 or 7 • Channel threshold for NCM default is high • Enabling IP ACCESS allows downloads over a local area network (LAN) or the internet • (Wide Area Network - WAN) using VeriFire™ Tools through the Noti•Fire•Net™ Web Server • (NWS), or a wide-area enabled NCS through a PC version of Noti•Fire•Net™ Gateway. Network Mapping • The Network Mapping softkey is only available if the Network Display Mode option is enabled. Panel Settings • Press the Panel Settings soft key on the Panel Program Menu 1 screen to choose panel settings • LOCAL CONTROL: Press this soft key to toggle between YES and NO. This option disables (NO) or • enables (YES) local panel control of the Signal Silence, System Reset, and Drill Fixed Function keys, as • well as SIGNAL SILENCE, SYSTEM RESET, and ACKNOWLEDGE soft keys. A setting of NO (disable) • turns the panel piezo sounder off, overriding the next field if PIEZO is set to ON. Default: YES