Professional Documents
Culture Documents
Arduino
GPS
Power supply
LCD
1. WWW.iosrjournals.org
2. WWW.ijritcc.org
3. International journal of advanced research in
computer engineering & technology (IJARCET),
volume 4 issue 4,april 2015.
4. Nishant Bharadwaj and Nitesh Aggarwal,
“Design and Development of “SURAKSHA”-A
women safety device”, Department of ECE ITM
UNIVERSITY ,Delhi ,India.
1.Mobile based women safety application:-
An ‘app’ is small specialised software program,
easily downloaded and installed in mobile such as
smart phones or tablets.
2.Smart Women Safety System:-
For security purpose here we are using GSM,GPS
and zapper circuit. In additional contains
instrument to create non-deadly electric stun in
cris. This is inserted in a belt.
The microcontroller occasionally screens status of
current spot futhermore continues checking.
If emergency switch is pressed it actuates discourse
circuit to make boistreous yelling sound to get
consideration of close by individuals for help.
3.A GSM based security device for women working
late night;-
The GSM based device gas two buttons, one for
sending distress call & another for cancelling distress
call.
Location, person name, photo will be displayed on
screen of cop control room and also text message is
sent to family members using SMS & also speed dial.
Arduino
GPS
GSM
LCD
Switch
Arduino uno is a
microcontroller board
based on ATmega328p.
It has 14 digital i/o pins.
6 analog inputs.
16MHZ ceramic
resonator.
USB connection, power
jack, ICSP header, and
reset button.
GPS receiver is used to
locate the coordinates.
GPS is used to detect
latitude and longitude of
any location on earth.
It will send coordinates
by $GPRMC string from
GPS module data.
It has 6 pins.
We are using 3 pins in
our project.
Vcc (red) is connected
to IOREF.
Tx (blue) to pin 5.
GND (black) to ground.
SIM card is mounted
upon GSM modem.
It is used to transmission
of SMS from sender to
receiver.
It has 4 pins
Tx,Rx,5v,GND.
We are using 3 pins.
Tx is connected to pin 8.
Rx to pin 9.
GND to ICSP header.
Power supply is given
externally.
It can display 16
characters per line and
there are two such lines.
Each character is
displayed by 5*7 pixel
matrix.
LCD has two registers,
namely command and
data.
Ithas two
connections.
One is connected to
ground.
Another is connected
to pin 4.
Arduino IDE
Start