Professional Documents
Culture Documents
3
WHAT IS FIRE …………
4
FM-200® is a colorless, liquefied
compressed gas. –
Heptafluoropropane
It is stored as a liquid and dispensed
into the hazard as a colorless,
eclectically non-conductive vapor
It is clear and does not obscure vision.
FM-200® does not displace oxygen
It is safer for use in occupied spaces
without fear of oxygen deprivation
5
6
PROTECTED AREAS
7
What Is A Total Flooding Fire
Suppression System?
Detect
Control
Suppression
8
SMOKE
DETECTORS
REMOTE ALARM
INDICATORS
MANUAL RELEASE
STATION
ABORT SWITCH
9
Working in a cross
Zone Scenario.
Covering range –84
Sq.m
Activation information
by local Led indication
on the detector
10
Unseen area smoke
detector Indication
!!! (Below floor ,
Upper floor and
Trenches )
11
Manual
Operation….
incase of Fire !!!
Direct discharge
of FM200 gas in
protected area –
With out any
time delay
Do not try to
reset ….( Only
trained person )
12
ELECTRIC CONTROL HEAD
13
Remove The
Safety Tag and
Pull the Lever ..To
activate the
System Manually
14
SYSTEM OPERATION: 1ST STAGE
15
INDICATION OF
FIRST STAGE OF
SMOKE
DETECTION
16
Find the Area-
Where You got
the
Alarm…………….
Inform Health &
Safety Dept.
call 999 (Fire
Dept.)
Close the Door &
move to Master
point
17
SYSTEM OPERATION: 2ND STAGE
18
Actual Fire
Indication.
Ready to Vacate
the Area !!!!!
After 30 Sec. FM
Gas will
Discharge……….
19
Inform Health &
Safety Dept.
Call. 66633188 - 44897362
Dial 999 To Fire
Department.
Close the Door & Go
to Master Point
If found it is false
alarm & its required
to stop the novec
1230 Discharge
!!!!!!!! Press & Hold
Abort Switch
20
Press & Hold !!!!
ACTION…
Stop the FM 200
GAS discharging
Hold Until reset
the panel
With out resetting
the panel it will
cause to start
again 30 Sec. time
count.
21
How to reset the panel
22
SYSTEM OPERATION: 3RD STAGE
23
Indication Of
FM200 Gas
Discharge…
Do not enter
with out
Authorization.
24
25
26
27
Maintenance Requirements for Fire
Suppression System
28
Monthly Maintenance
29
Semi-Annual Inspection
(To Be Performed by Trained Person)
• Inspect system for missing or damaged equipment
• Test system for proper operation
– Control Panel functions
– Detectors, aborts, pull stations, control heads and
notification appliances
– Pressure switches and auxiliary connections
– Check for proper sequence of operation and time
delays
- Test all detection and control devices as per NFPA 72
30
QUESTION ?
31