Continuous reading data (PID = Parameter ID) - -There are digital and analog values in live motor speed such as temperature, load, lambda reading etc. Frezze frame
- - The ECU takes a sample
- of all emission-related values, at the exact moment of a - failure Request for fault codes
- - - This mode allows all Fault
codes to be extracted from the ECU memory - (DTC - Data / Diagnostic Trouble Code) stored in it Clear fault codes and stored values.
- - With this mode it is possible to
erase all the codes stored in the Module - Engine and Transmission Control Module (PCM), including the - fault codes and table of temporarily recorded data - - if the fault persists, the MIL light will turn on again Oxygen test result
- - Returns the results of the tests
performed on the sensors - oxygen to determine their operation and the efficiency of the converter Result of non-permanent control tests. - The most common tests performed on this option are the following: - - Combustion failures - - Fuel system - - Catalyst - - Evaporative system. - - Secondary air system. - - Air conditioning refrigerant. - - Oxygen Sensors - Oxygen sensor heating. - - Exhaust gas recirculation (EGR). Show pending fault codes This mode allows all pending fault codes to be read from the ECU memory that have not been previously repaired or deleted. Special control mode This mode allows you to test actuators. With this role, staff authorized can activate and deactivate actuators such as fuel pumps, idle valve, among other actuators of the automotive system.