Professional Documents
Culture Documents
x WRONG ANSWER
a) MMA
b) MIG
c) TIG
d) SAW
QUESTION 3
c) Improve penetration
a) Throat thickness
b) Nominal penetration
c) Leg length
.
QUESTION 11
The welding current in MIG/MAG welding is controlled by
which parameter?
a) Dip transfer
b) Spray transfer
c) Globular transfer
a. 15-20volts.
b. 30-40volts.
c. 20-25volts.
d. 40-50volts.
QUESTION 14
d) Use of inductance
QUESTION 15
A code gives the acceptance requirement for excess weld
metal as h ≤1mm + 0.1b, max 5mm. Where ‘b’ is the width
of the excess weld. For which of the following situations is
the excess weld metal acceptable?
a) b = 15 h = 3.0
b) b = 22 h = 3.0
c) b = 28 h = 4.0
d) b = 40 h = 5.4
QUESTION 16
Which of the following defects could occur when
carrying out autogenous TIG welding of non-
deoxidised steel:
a) Undercut
b) Porosity
c) Tungsten inclusions
d) Lack of fusion
QUESTION 17
Which of the following statements regarding MIG/MAG
welding is true ?
a) 50-70°C
b) 90-120°
c) 150-200°
d) 200-250°
QUESTION 19
The static output characteristic required for MIG/MAG
welding would be
a) Constant current
b) Constant voltage
c) Constant polarity
d) Constant amperage
QUESTION 20
The correct term for extra weld metal on the external
surface of a butt weld is:
a) Cap
b) Reinforcement
d) Crown
QUESTION 21
Which of the following variables will be most affected by
variations in arc length when MMA welding?
a) Travel speed
b) Amperage
c) Polarity
d) Voltage
QUESTION 22
A C Mn steel designated as ‘Z’ quality will have what?
a) z10
b) a10
c) s10
d) t10
QUESTION 24
When using carbon dioxide as a shielding gas, a gas heater is
used to prevent:
a) 1.114:1
b) 2.414:1
c) 1.514:1
d) 1.414:1
QUESTION 27
Low hydrogen MMA electrodes are baked prior to use in order
to:
a) 35 joules at -30°C
b) 35 N/mm² tensile strength
c) 35 ksi tensile strength
d) 350 N/mm² yield strength
QUESTION 30
Why is it better to used activated TIG tungsten electrodes, in
preference to un activated TIG tungsten electrodes;
b) Alternating current