Professional Documents
Culture Documents
Thesis Propsal
Thesis Propsal
UNIVERSITY
COLLEGE OF ENGINEERING
DEPARTEMANT OF ELECTRICAL AND COMPUTER ENGINEERING
Proposal Presentation
on
Design and Performance Analysis of Frequency Scanning
Microstrip Array Antenna for Vehicular Adhoc Network
STREAM OF: COMMUNICATION ENGINEERING
Name of Student: ID NO
1.Goftaye Techane …………………………………..Eng/R/032/10
2.Misgana Zewde……………………………………Eng/R/160/10
3.Teshale Asfaw………………………………………Eng/R/705/10
4.Sofia Sultan…………………………………………Eng/R/636/10
5. Beliyou Solomon……………………………………Eng/R/013/10
WELL COME TO
OUR
PRESENTATION
Outlines
Introduction of the Project
Statement of the Problem
Significance
Scope
Objective of the Project
Literature review
Methodology
References
1.Introduction
The antenna, often known as a device, is defined by the
IEEE Standard Definition of Terms for Antennas as "a tool
used in a mechanisms for emitting or receiving radio waves.
1
3. Significance of the study
The biggest challenges of this thesis work is to provide
array antenna design that can be used for frequency
selective environment with increased beam steering
capacity and cover larger coverage area without using
phase shifter, filter and switches.
6
4. Scope of the study
In VANET making a real life experiment at larger scale
is very difficult and expensive because it requires
technological resources to install antennas, to deploy
and mount on board and road side units.
7
5. Objective
General objective
To design and performance analysis of Frequency Scanning
Microstrip Array Antenna for Vehicular Ad Hoc Network.
Specific objective
To make mathematical modelling for patch antenna and
frequency scanning Microstrip array antenna.
To Design a single Microstrip patch antenna using
frequency range from 22.5GHZ to 23GHZ.
To make performance analysis between single, 2x1, 4x1
frequency scanning Microstrip patch antenna.
6.Literature review
A microstrip array antenna is currently they’re one of the most
common antenna type used widely. Because they are
lightweight, they may be utilized in a variety of applications
where surface volume is important. Fabrication in big
quantities will be simple since they demand a reduced cost.
They have several drawbacks, such as a narrow range band
width and limited power handling, however some of these may
be addressed by employing novel feeding techniques and
patch configurations [5].
9
7. Methodology
Material
Typicaly software in antenna design and for analytical
modeling called matlab software can be used.
10
Flow diagram
11
11. References
[1] X. Yang, W. Geyi, and H. Sun ( 2017), “Optimum Design
of Wireless Power Transmission System Using Microstrip
Patch Antenna Arrays,” IEEE Antennas Wirel. Propag. Lett.
vol. 16, no. c, pp. 1824–1827.
12
THANK YOU
FOR YOUR ATTENTION!!!!
16