Professional Documents
Culture Documents
Module 3
Module 3
1
Why Factor of Safety (FOS)
The external loads cause internal stresses in the elements and the
component size depends on the stresses developed. Determination of stresses in structural
or machine components would be meaningless unless they are compared with the material
strength.
If the induced stress is less than or equal to the limiting material strength then the
designed component may be considered to be safe and an indication about the size of the
component is obtained. For design purpose an allowable stress is used in place of the critical
stress to take into account the uncertainties including the following:
Uncertainty in loading.
In-homogeneity of materials.
Various material behaviors. e.g. corrosion, plastic flow, creep.
Residual stresses due to different manufacturing process.
Fluctuating load (fatigue loading).
Safety and reliability. 2
Theories of Failure
Failure occurs when Material starts exhibiting In-elastic behavior
Brittle and Ductile materials – different modes of Failures – mode of Failure Depends on
Loading
Ductile Materials – exhibit Yielding – Plastic Deformation before Failure
Brittle Materials – no Yielding – Sudden Failure
Yield/Ultimate Stress – Material property
Factor of safety (FS)