Professional Documents
Culture Documents
8 watt IC
amplifier
N E X T
The schematic diagram of IC LM 3838 watts amplifier
is shown in figure 57. The IC amplifier can be used for
an electric guitar and also to drive booster amplifier.
N E X T
This amplifier is conservatively rated 100 watts at 8
ohms although it has received power wave above its
rated output. In case you are one of the many
enthusiasts who are always keeping an eye for high
power, this amplifier merits your attention If you are
not yet satisfied with 100 watts output please amplify
your delivers 250 watts at four ohms speaker system.
N E X T
Circuit description
Circuit
description
N E X T
For NPN output transistors shared the heat generated
at high power amplification and at the same time add
up to total output of the amplifier. The bias of the
driver transistor is controlled by bias diode S TV-3
and15 ohms resistor (R12). Are there bias diode such
as SV-2 and SB-4 can substitute STD-3 originally
specified however a change of bias diode requires a
change of R12 series resistor.
N E X T
depending on his practical experience . This is very
important for a beginner to follow recommended
procedures carefully in order that he can build his
amplifier successfully. Technics applied in testing a
new amplifier are actually the same as those of
troubleshooting one. For this reason, the experience
gained in building down before is applicable in
troubleshooting since the same test are conducted for
both.
Don'ts in 2.
N E X T
connected to the PCV. And open bias circuit will
testing the
damage the drivers transistors and burn their emitter
resistors.
amplifier
3.
Test the amplifier one after the other period connect
supply on the channel under test leaving the other
unconnected
1.
Don'ts in
shorted.
Do not test amplifier without the bias diodes S TV-3
connected to the PCV. And open bias circuit will
damage the drivers transistors and burn their emitter
N E X T
testing the
resistors.
5.
3.
Do
Testnot
thesubstitute
amplifier a blown
one afterfuse
the with
otherjumper
periodwire. A
connect
larger
supplywire defeats the under
purposetestofleaving
the fuse.
theOn the
amplifier
on the channel other
other hand, smaller wire is blown frequently.
unconnected
4..
Do not connect the speaker. The supply voltage
appears at the output if any of the output transistors is
shorted.
Do’s in testing
amplifier
Pre-test the amplifier before it is installed on
the chassis. It will be easier and faster to
inspect in case of trouble.
Do’s in testing 2.
N E X T
Connect the power supply to other channel and switch
amplifier
on the power Quickly measure the voltages across the
test points indicated at the PCB as shown in figure 68.
The voltages of the best punch should be close to the
supply voltage. If the voltages are equal, that is fine.
Switch off the amplifier and fill the parts of sign of
overheating. The same voltage measurement can be
taken at the emitter dash collector of the drivers
transistors .
Servicing the
amplifier
Servicing
the
amplifier
N E X T
The three points in the amplifier indicate it’s condition.
The first test point which is the emitter and collector of
the driver and power transistors shows if the driver, pre
driver, and differential amplifier transistors.
N E X T
Repairing a speaker is not a difficult job to do. There are
no special tools needed. Most of them are basics tools of
a technician. A winding machine is of course, costly but it
makes the work easy and fast. You can do without it,
Winding voice coil by hand. The coil is wound in a few
turns, which can be done even without a counter. One
could simply measure the width or spread of the original
voice coil and match it. Another practical method is to
unwind the coil and rewind a new one of the same length
and size of wire.
N E X T
Presentation
GOOGLE SLIDES POWERPOINT CANVA
Click on the "Google Slides" button Click on the "PowerPoint" button Click on the "Canva" button
below this presentation preview. below this presentation preview. under this presentation preview.
Click on "Make a copy." Start editing your presentation. Start editing your presentation.
Start editing your presentation. Download and install the fonts You need to sign in to your Canva
You need to sign in to your used in this presentation as account.
Google account. listed on the next page.
Agenda WRITE YOUR AGENDA POINT
N E X T
WRITE YOUR AGENDA POINT
N E X T
I'm Rain, and I'll be sharing with
you my beautiful ideas. Follow
me at @reallygreatsite to
learn more.
Elaborate on a personal
detail you want to share.
Get to
N E X T
Elaborate on a personal
detail you want to share.
Know Me
Elaborate on a personal
detail you want to share.
Add a Section
N E X T
Header
My
Projects
What can you say about your projects?
Share it here!
N E X T
Write Your
Topic or Idea
Elaborate on what you want to discuss.
Series 3 Series 4
N E X T
400
300
200
100
0
0 10 20 30
Write an
original
statement
N E X T
or inspiring
quote
— Include a credit, citation, or supporting message
ADD A MAIN POINT ADD A MAIN POINT
N E X T
What do you do during your What do you do during your
free time? Write them here! free time? Write them here!
95%
N E X T
Elaborate on the featured statistic.
12 million
Elaborate on the featured statistic.
ADD A MAIN POINT
Elaborate on a personal detail
you want to share.
Add a
N E X T
ADD A MAIN POINT
Timeline Page
Elaborate on a personal detail
you want to share.
N E X T
Thank you for listening.
N E X T
NAME SURNAME NAME SURNAME NAME SURNAME
Title Title Title
S W
STRENGTHS WEAKNESSES
What are you doing well? Where do you need to improve?
What sets you apart? Are resources adequate?
What are your good qualities? What do others do better than you?
N E X T
O T
OPPORTUNITIES THREATS
What are your goals? What are the blockers you're facing?
Are demands shifting? What are factors outside of your control?
How can it be improved?
Add a Chart Page
Name
Job Title
N E X T
Name Name
Job Title Job Title
N E X T
everyone to use thanks to the following:
Happy designing!
Fonts In this
Presentation
N E X T
This presentation template uses the
following free fonts: