Professional Documents
Culture Documents
Tiggo 2.4at Maintenance Guide
Tiggo 2.4at Maintenance Guide
一、整车差异件清单
售后服务部
隔热罩 T11-1008140 1 —— —— 4
螺栓 480-1008143 3 —— —— 1
悬置双头螺柱 T11-1001412 2 —— —— 1
左悬置支架 T11-1001211DA 1 左悬置支架 T11-1001211CA 1
售后服务部
List of Different Accessory
SQR7240T11T SQR7247
Accessory Name Accessory No. Quantity Accessory Name Accessory No. Quantity
Bolt 480-1008143 3 —— —— 1
Mount T11-1001412 2 —— —— 1
Double-end Bolt
Left Mount Bracket T11-1001211DA 1 Left Mount Bracket T11-1001211CA 1
售后服务部
接上页
零件名称 零件号 数量 零件名称 零件号 数量
前悬置支架 T11-1001611DA 1 前悬置支架 T11-1001611CA 1
Accessory Name Accessory No. Quantity Accessory Name Accessory No. Quantity
Air Strainer with Intake T11-1109110CA 1 Air Strainer with Intake T11-1109110 1
Pipe Assembly Pipe Assembly
Air Intake Rubber Pipe T11-1109210BA 1 Air Intake Rubber Pipe T11-1109410 1
Bolt Q184C1230 2 —— ——
Fuel Tank Seal Ring A11-1101151 1 Oil Pump Seal Ring T11-1106611 2
Back Oil Pipe III Assembly T11-1104250FA 1 Back Pipe III Assembly T11-1104220
Fuel Tank Protect Panel T11-1101121 1 Fuel Steam Hose III T11-1104351 2
ⅠFuel Tank Fixed Belt T11-1100015 1 Fuel Tank Fixed Belt T11-1100010
Assembly I Assembly
Fuel Tank Fixed Belt T11-1100025 1 —— ——
Assembly II
售后服务部
Bolt Q1840610 2 —— ——
Bolt Q1840640 2 —— ——
Bolt Q1800616 2 —— ——
Clamp B11-1503061 1 —— ——
Bolt Q1840612 2 —— ——
Left Constant Velocity Joint T11-2203010DA 1 Left Front Drive Shaft T11- 1
Drive Shaft Assembly Assembly 2203020BC
Right Constant Velocity T11-2203020DA 1 Right Front Drive Shaft T11- 1
Joint Drive Shaft Assembly Assembly 2203020BC
Automatic Shift Control T11-1504010 1 Automatic Shift Control T11-1703010 1
Mechanism Assembly Mechanism Assembly
Soft Shaft harness Assembly T11-1504310 1 Soft Shaft harness T11-1703090 1
Assembly
combination Nut Q32208 1
Front of left Front Side T11-5101300BD 1 Front of left Front Side T11-5101300 1
Member Assembly Member Assembly
Front Part of Left Front T11-5101310BD 1 Front Part of Left Front T11-5101310 1
Side Member Side Member Assembly
Assembly
售后服务部
二、发动机部分
售后服务部
II. Engine
售后服务部
1 、 发动机机械部分
The mechanical part of the engine of SQR7240T11T is the same as that of SQR7247, exce
pt the difference in engine mount, air intake system and discharge system. Please refer to t
he Maintenance Manual of Mechanical Part of Mitsubishi Engine of Eastar published by th
is Department.
售后服务部
左悬置
序 名称 扭
数量
号 图号 矩
⑥
左悬置软垫总成
① 1
T11-1001110BA
③
左悬置支架
② 1
T11-1001211DA
⑤
② ③
六角法兰面螺栓
Q184C1025
4 70±5N.m
六角法兰面螺栓
④ 1 70±5N.m
Q184C10125TF6
①
六角法兰面螺母
④ ⑤
Q330C10
1 70±5N.m
自锁螺母
⑥ 4 80±5N.m
⑥ AQ330B12
售后服务部
Left Suspension
Seri Quant
Name and Figure No. Torque
al ity
No.
⑥
Left Mount Soft
① Gasket Assembly 1
T11-1001110BA
③
Left Mount Bracket
② 1
T11-1001211DA
⑤
② ③
Hexagonal Flange Bolt
Q184C1025
4 70±5N.m
Locknut
⑥ 4 80±5N.m
⑥ AQ330B12
售后服务部
右悬置
序 名称 数 扭
号 图号 量 矩
④ ①
右悬置软垫总成
1
③ T11-1001310
六角法兰面螺栓 70±5N.
② 2
Q184C1025 m
螺栓 35±5N.
③ 1
Q1400820 m
⑤
六角法兰面螺母 70±5N.
① ④ 2
Q330C10 m
①
②
① 六角法兰面螺栓 70±5N.
⑤ 1
Q184C1040TF6 m
售后服务部
Right Suspension
Ser
Qua
ial Name and Figure Torque
ntity
No. No.
Hexagonal Flange
② Bolt 2 70±5N.m
Q184C1025
Bolt
③ 1 35±5N.m
Q1400820
⑤ Hexagonal Flange
① ④ Nut 2 70±5N.m
① Q330C10
②
① Hexagonal Flange
⑤ Bolt 1 70±5N.m
Q184C1040TF6
售后服务部
前悬置 序 名称 数 扭
号 图号 量 矩
前悬置软垫总
② ① 成 T11-1001510 1
①
① CA
①
⑥
前悬置支架 T1
② 1
1-1001611DA
六角法兰面螺 70±5N.
③ 1
栓 Q184C1090 m
六角法兰面螺 70±5N.
④ 1
母 Q330C10 m
③ 、④
六角法兰面螺 70±5N.
⑤ 2
⑤ 栓 Q184C1025 m
六角法兰面螺
80±5N.
⑥ 栓 Q184B1225T 2
m
F6
售后服务部
Front Suspension Ser
Qua
ial Name and Figure Torque
ntity
No. No.
Hexagonal Flange
③ Bolt 1 70±5N.m
Q184C1090
Hexagonal Flange
④ Nut 1 70±5N.m
③ 、④ Q330C10
Hexagonal Flange
⑤ Bolt 2 70±5N.m
⑤ Q184C1025
Hexagonal Flange
⑥ Bolt 2 80±5N.m
Q184B1225TF6
售后服务部
后悬置 序号
名称
图号
数量
扭
矩
后悬置软垫总成 T11-1001
① 1
710BA
②
① ③ 后悬置支架 T11-1001811D
① ② 1
A
①
① ③
六角法兰面螺栓 Q184B12
1 105±5N.m
95TF6
④
⑧
① ④ 六角法兰面螺母 Q330B12 1 105±5N.m
六角法兰面螺栓 Q184B12
⑤ 1 105±5N.m
35TF6
六角法兰面螺栓 Q184B12
⑥ 1 105±5N.m
40TF6
⑦ ⑤ ⑥ 六角法兰面螺栓 Q184B12
① ① ⑧ 2 80±5N.m
30TF6
售后服务部
Rear Suspension Serial
No. Name and Figure No.
Quanti
ty
Torque
The electronic fuel injection system of the engine of SQR7240T11T is the same as
the electronic fuel injection system of the engine of Eastar 4G64. Please refer to th
e Maintenance Manual of Electronic Fuel Injection System of Eastar 4G64 and 4
G63 published by this Department.
售后服务部
The control principle diagram of the engine’s electronic fuel injection system is the s
ame as that of Eastar F4A42. PLease refer to the Annex 1 hereto
售后服务部
三、自动变速箱部分
The control principle diagram of the automatic transmission is the same as that of Ea
star F4A42. PLease refer to the Annex 2 hereto.
售后服务部
四、电器部分
Compared with SQR7247, the electrical equipment of SQR7240T11T is the same as that of
SQR7247 except the additional control part of automatic transmission. Please refer to the
Maintenance Manual of T11 Electric Circuit published by this Department.
售后服务部
由于增加了自动变速箱控制,公司对下列电器
元件做了重新设计,增加了自动变速箱控制部分
的线路。
1 、前舱线束 T11-3724010TA
2 、仪表板线束 T11-3724030TA
3 、室内线束 T11-3724050TA
4 、发动机线束 T11-3724180TA
5 、前舱电器盒总成 T11-3723010BA
6 、仪表电器盒总成 T11-3723060BA
7 、正极线束总成 T11-3724011TA
8 、组合仪表 T11-3820010DB
售后服务部
接风扇控制器
接左前转向灯
接左前轮速传感器 接右前转向灯
接左前大灯 搭铁线 2
接 ABS 控制器
搭铁线 1
接右前转向灯
雨刮电机 接前舱电器盒
制动液位传感器
接报警喇叭
左前转向灯
搭铁线 3
接仪表电器盒 H
接仪表电器盒 D
接 ISU 控制器电源
接仪表线束 B 接室内线束
接仪表新线束 A
售后服务部
Engine Compartment Left Front Turn Signal Lamp
Harness (2.4AT)
Increase To Front Wash Motor
To Left front Fog Lamp
To Althorn
To Compressor
To Rear Wash Motor
To Buglelet
To Battery Anode Fuse Block To Right Front Tachogenerator
To Drive Turn Signal Switch
To Right Head Lamp
To Fan Control
To Left Front Turn Signal Lamp
To Annunciator
Left Front Turn Signal Lamp
To Ground Harness 3
To Instrument Electrical Box H
To Instrument Electrical Box D
To ISU Control Power Supply
1 号脚:电源
2 号脚: ECU 控制线
3 号脚:搭铁
售后服务部
Engine Compartment
Harness (2.4AT)
接 ECU C 接发电机
接碳罐电磁阀
接 ECU B
接 ECU A
接 TCU A
接曲轴位置传感器 接分电器 2
接 TCU B 接前舱线束
接 TCU C
接空气流量传感器
接地 接地
接喷嘴 2
接喷嘴 3 接喷嘴 4 水温传感器
凸轮轴位置传感器
接分电器 1 接暴震传感器
接步进电机 输出轴速度传感器
接水温传感器
接 EGR 阀
接马达
接机油压力开关
接选档开关
接前氧
接节气门位置传感器
接控制电磁阀
接输入轴转速传感器
售后服务部
Engine Harness To Instrument Harness A
To Instrument Harness B To Injection Nozzle 1
(2.4AT) To A/C Press Switch
To ECU D
To ECU C To Generator
To Carbon Canister solenoid valve
To ECU B
To ECU A
To TCU A
To Crankshaft Position Sensor
To TCU B To Engine Compartment Harness To Distributor 2
To TCU C
To Airflow Sensor
To Earth To Earth
To Injection Nozzle 2
To Injection Nozzle 4 Temperature Sensor
Water
To Injection Nozzle 3 Camshaft Position Sensor
增加:
凸轮轴位置传感器插件
空气流量传感器
仪表水温传感器插件
EGR 阀插件
自动变速箱系统插件
售后服务部
Engine Harness
(2.4AT)
On the basis of the engine harness of original Tiggo, the engine harness o
f
the 2.4AT makes the following changes:
Canceling:
Backup Lamp Switch Insertion Piece
Air Intake Temperature Pressure Sensor Insertion Piece
Speed Sensor Insertion Piece
Adding:
Camshaft Position Sensor Insertion Piece
Airflow Sensor
Instrument Water Temperature Sensor Insertion Piece
EGR Valve Insertion Piece
Automatic Transmission System Insertion Piece
售后服务部
凸轮轴位置传感器插件:
1 、搭铁
2 、到 ECU
3 、电源
空气流量传感器插件:
1 、 ECU 电源
2 、 ECU 85
3 、 ECU 90
4 、电源
5 、搭铁
6 、 ECU 72
7 、 ECU 19
售后服务部
Camshaft Position Sensor Insertion Piece:
1 、 Ground
2 、 To ECU
3 、 Power Supply
作用:
直接将发动机水温信号送到组合仪表。
EGR 阀插件 :
1 、电源
2 、 ECU 6 号脚
售后服务部
Instrument Water Temperature Sensor Insertion Piece:
Function:
Directly transmitting the water-temperature
signal of the engine to the combination
instrument.
1 、 Power Supply
2 、 ECU Leg 6
售后服务部
自动变速箱系统 :
包括:
输出轴速度传感器
输入轴速度传感器
控制电磁阀插件
换档开关插件
Including:
Output Shaft Speed Sensor
Input Shaft Speed Sensor
Control Solenoid Valve Insertion Piece
Selector Switch Insertion Piece
增加:
换档开关插件
此插件位于换档杆下方,将换档杆位置
信号提供给组合仪表,并将手动加、减
档信号提供给 TCU 。原理与东方之子
2.4AT 相同。
售后服务部
In-door Harness
2.4AT
On the basis of the engine harness of original Tiggo, the in-door harness of
the 2.4AT makes the following changes:
Canceling:
Acceleration Sensor Insertion Piece
Adding:
Gear Shift Switch Insertion Piece
注:红色圈出部分为新增或更改
售后服务部
Engine Compartment Electric Box Assembly
Oil Pump
Fuse
compressor
fan
generator
Ignition
Blower
Fuse
Beam
Standby
Switch
l
Coi F7 Blower
Tardiness
Fuse Relay
(Tardiness
Fuse) Fan Standby
Control
Right Front
Left Front
Right Front
Left Clearance
F8
Brake
Beam
High
Beam
High
Beam
High
Lamp
p
Lam
Actuator
30A (Tardiness
Plucking
Relay 30A (Tardiness
Fuse) Main Blower Oil
Fuse) Actuator Pump
Device
Rear Fog Light
Actuator Standby Rear Fog Front Fog High Beam Low Beam
Standby
Relay Relay Light Relay Light Relay Relay Relay Relay
售后服务部
仪表电器盒总成
注:红色圈出部分为新增或更改
售后服务部
Instrument Electric Box Assembly
Device
( Tardines
Compressor s Night Light
Compressor Rear Wiper Blade
Fuse ) Adjuster
Relay
( Tardines
Standby Relay s
Key Switch Relay Coil
Fuse )
Power Combination
Rearview Mirror Heat
Supply Instrument
售后服务部
五、底盘部分
V. Chassis Part
The chassis part of SQR7240T11T is the same as that of SQR7247. Please refe
r to the Maintenance Manual of T11 Chassis Part published by this Department.
售后服务部
六、车身附件及车身尺寸部分
The body accessory and body dimension part of SQR7240T11T are the same as th
ose of SQR7247. Please refer to the Maintenance Manual of T11 Body Accessory
and Body Dimension Part published by this Department