Professional Documents
Culture Documents
OBJECTIVES
Recognize some of the electronic components. Gain experience in assembling and soldering components to the circuit board. Check and test components such as diodes, LED and resistors. Test and measure some parameters of the power supply. Trouble shooting for the faulty components and power supply.
APPARATUS
Plastic casing.
APPARATUS
APPARATUS
Resistor
APPARATUS
Solder
Wire
PROCEDURES
Circuit configuration
PROCEDURES
Circuit configuration
PROCEDURES
PRECAUTION
Check all diode and LED to make sure they are in good condition using ohmmeter MAKE SURE the positive (P) and negative (N) polarity of the diodes are correctly connected Properly solder all components leads to the circuit board. Make sure there is no dry joint or short circuit between copper tracks of the circuit board Make sure cut short all the components leads Make sure connection made between wire are insulate properly to avoid contact
FINISH