The process for measuring hardness values has a target of 192, lower specification limit of 160, and upper specification limit of 250. Based on 557 samples, the process mean was 221.291 with a standard deviation within samples of 8.52015 and overall of 8.77818. The process capabilities were determined to be within specification but potential improvement was identified as the observed performance recorded no parts outside the specification limits while the expected performance predicted some parts could be outside limits.
The process for measuring hardness values has a target of 192, lower specification limit of 160, and upper specification limit of 250. Based on 557 samples, the process mean was 221.291 with a standard deviation within samples of 8.52015 and overall of 8.77818. The process capabilities were determined to be within specification but potential improvement was identified as the observed performance recorded no parts outside the specification limits while the expected performance predicted some parts could be outside limits.
Copyright:
Attribution Non-Commercial (BY-NC)
Available Formats
Download as PPT, PDF, TXT or read online from Scribd
The process for measuring hardness values has a target of 192, lower specification limit of 160, and upper specification limit of 250. Based on 557 samples, the process mean was 221.291 with a standard deviation within samples of 8.52015 and overall of 8.77818. The process capabilities were determined to be within specification but potential improvement was identified as the observed performance recorded no parts outside the specification limits while the expected performance predicted some parts could be outside limits.
Copyright:
Attribution Non-Commercial (BY-NC)
Available Formats
Download as PPT, PDF, TXT or read online from Scribd