Professional Documents
Culture Documents
Standard Assembly of H-Type If Connector
Standard Assembly of H-Type If Connector
2006-12-04
Step 1 Insert lock nut, flat ring and rubber gasket to the IF cable
30mm
(1)
(2)
10mm
Step 3 Shave off the outer insulator about 10 mm and shave to taper on the side edge
(1)
(2)
Step 4 Insert clamp ring to the IF cable. If the black sheath exceeds the ring, We should cut out the exceeding part to keep the ring and sheath in line.
(3)
(4)
Step 6 Cut the aluminum shield in about half and divided. Cut out the exceeding parts and fold back aluminum shield.
(2)
(3)
Step 7 Overlap aluminum shield with braided shield. Cut out inner insulator from the root and remove it.
Step 8 Cut core conductor in 17 mm and taper the end of core conductor using file.
(1)
(2)
(1)
(2)
Step 10 Set metal bush/insulator in the connector correctly so that the core conductor may enter a center pin.
(1)
(2)
1.5mm
Step 11 Turn the lock nut to tighten the connector. Turn only lock nut.