You are on page 1of 2

Transmission:

GM 4T40E
07X218

Transmission Code: 071


(4T65E adapter)

Dedicated Harness Sets:

SOLENOID TEST:
Solenoid
Solenoid A (1-2/3-4) Solenoid B (2-3) Lock-Up (pulsed) EPC (pulsed)

(Engine off)
AMPS Cold-Hot
0.6 - 0.3 0.6 - 0.3 0 - (0.6 - 1.2)
Duty MIN - MAX

TranX Setting
Gear 1 Gear 2 Gear 5 Gear 8

Output Channel
1 2 5 8

Resistance Cold-Hot
20 - 40 20 - 40 11 - 17 3.5 - 4.6

0 - (0.9 - 1.8)
Duty MIN - MAX

CAUTION:
Always come to a COMPLETE STOP & TURN ENGINE OFF before changing test modes SHIFT/MONITOR TEST
GEAR
1st 2nd 3rd 4th

Solenoid A
ON OFF OFF ON

Solenoid B
OFF OFF ON ON

Lock-Up (pulsed)
OFF ON/OFF ON/OFF ON/OFF

EPC (pulsed)
Select Duty Select Duty Select Duty Select Duty

Notes:

EPC Solenoid current read on output channel 8 for solenoid test, shift test and for monitor mode. EPC Solenoid duty cycle displayed in monitor mode is actual duty cycle from ECM. Lock Up is normally activated in 2nd, 3rd and 4th Gears. See other side for connector diagram. Polarity = Common Positive

TranX 2000 Manual

GM: Page 7

Transmission:

GM 4T40E
TOT Sensor Testing
Range B (Sensor 2) Red Red Red Range C (Sensor 3) Red Connect Multimeter to Sensor Module Test Points 5 & 6 Range A (Sensor 1)

Pressure Switch Settings


Gear Park Reverse Neutral Drive (1 to 4) Manual 3 Manual 2 Manual 1

GREEN GREEN GREEN GREEN


Red Red

Resistance
2981 - 4018 1915 - 2550 1260 - 1660 848.8 - 1105 584.1 - 753.4 410.3 - 524.2

Temperature
68 F 86 F 104 F 122 F 140 F 158 F 176 F 194 F 212 F

GREEN
Red Red Red

GREEN GREEN GREEN GREEN


D C

GREEN GREEN
B A E

GREEN

CONNECTOR: (Looking into harness connector)


S

293.7 - 371.7 213.9 - 268.2

R P

N M L

158.1 - 196.8
V U T

Wiring Chart
Case Connector Pin Number A B C D E L M N P R S T U V TranX 2000 Harness Wire Blue Green Yellow Gray Red,or Red/Brown Red/Blue Stripe White/Red Stripe Orange Light Green White Pink Purple Brown White/Green TranX 2000 Manual Vehicle Function Solenoid A Solenoid B EPC Power EPC Ground Power to Solenoids TOT Sensor TOT Sensor Pressure Switch (A) Pressure Switch (C) Pressure Switch (B) 3-2 Control Solenoid Lockup Solenoid TCC Release Speed Sensor Sensor 5 Test Point Sensor 6 Test Point Sensor LED 1 Sensor LED 3 Sensor LED 2 Channel 3 Channel 6 Sensor 4 Test Point Sensor 8 Test Point TranX 2000 Output Location Channel 1 Channel 2 Channel 7 Channel 8 TranX 2000 25 Way Pin 7 8 1 2 12 or 13 19 20 15 17 16 5 4 18 22 GM: Page 8

You might also like