Professional Documents
Culture Documents
634047557683228750
634047557683228750
By: Jayashree.P
Contents
1. 2. 3. 4. 5.
History of Jet Engines Introduction Parts Of Jet Engine How A Jet Engine works Types Of Jet Engine
5.1 Ramjet
Continued . . .
6. 7. 8. 9. 10. 11. 12. 13. 14. Comparison Of Turbojets Jet Engine Vs Rockets Difficulties Suggestion For Improvement Merits And Demerits Jet Engine Uses Conclusion Future Vision References
The first jet engine was built by Egyptian scientists during 100 B.C
Dr. Hans von Ohain and Sir Frank Whittle were the main developers.
2.Introduction
Jet engine is nothing but a Gas turbine. It works under the principle of Newtons third law It states that For every acting force there is an equal and opposite force. Gas turbine operates like toy balloon
Jet engines move the airplane forward with a great force that is produced by a tremendous thrust and causes the plane to fly very fast.
Continued . . .
Air Intake
sucked in by the compressor
Fuel Burner
Fuel is mixed with the air, and electric sparks light the air, causing it to combust.
Compressor
Combustion Chamber
series of vanes and stators. The vanes rotate, while the stator remains stationary. compressor speed and temperature increases gradually
The air is burnt. Increase in the temperature of the air, thus increases the pressure inside the engine.
Continued . . .
Turbine
Works like a windmill The blades gain energy from the hot gases moving past them. This movement is used to power the compressor.
The hot air rushes out of the nozzle. high pressure Hot air rushes out at very high speed
5.1 Ramjet
It has no moving parts. Its compression ratio depends forward speed. It has no static thrust guided-missile systems, vehicles use this type of jet Space
on
5.2 Turbojet
The turbojet engine is a reaction engine. Substantial increases in thrust can be obtained by employing an afterburner
5.3 Turbofan
The objective of this sort of bypass system is to increase thrust without increasing fuel consumption. It achieves this by increasing the total air-mass flow and reducing the velocity within the same total energy supply.
5.4 Turboprop
A turboprop engine is a jet engine attached to a propeller. . Modern turboprop engines are equipped with propellers that have a smaller diameter but a larger number of blades for efficient operation at much higher flight speeds
5.5 Turboshaft
It does not drive a propeller. it provides power for a helicopter rotor. It permits the rotor speed to be kept constant even when the speed of the generator is varied
Has got compressor, turbine Heavy Mach no. < 2 Starts with zero initial velocity
No compressor, turbine Light in weight Mach no 2 to 5 Start only at Mach 2 and above
9. Difficulties
Time scale of combustion Total temperature in combustion chamber Coupling the air frame to the engine Scramjet cannot operate below mach 4
Employ active cooling Designing better materials and alloys which retain their strength at high temperatures Smart structures Structure and material which change their shapes and properties in flight. Design engines which switch from scramjets to ramjets.
Demerits Of Jet Engines Over IC engine Thermal efficiency of Jet engine is low compared to IC engine Difficult to start
Weight and speed of jet engine per HP developed is higher than IC engine. Ignition and lubricating systems are much simpler in jet engine than IC engine.
The jet engine is not only used on aircraft but on boats, where water jets are used to propel the boat forward..
12.Conclusion
Normal type of jet engine is used for domestic purpose i.e. Traveling, carrying goods etc. Ram and scram type of jet engines used in only in Defence sector. Because it travels at supersonic speed and generally high level of training is required. Since it travels at such a speed it is can not used for traveling. So that common type of jet engines are very common in use.
Decreased gross lift off weight > Smaller facilities & easier handling Leading to higher safety Flights can be aborted, whiles the vehicle glides back to earth Missions can be more flexible Wider range of emergency landing sites for intact abort
14. Bibilograph
http://www.freepatentsonline.com Harris, William S. http://www.freepatentsonline.com Jaeckel, Ernst (DE) http:// www.google.com http:// www.boeing.com http:// www.jet engine.com
Thank You