Professional Documents
Culture Documents
Analog Quiz
Analog Quiz
Marks 30
Question 1:- As Bias Current I1 increase then Voltage Gain (Vout/Vin) of the amplifier shown below -
Question 2:- If Length L1 of Mosfet M1 increases then Voltage Gain (Vout/Vin) of the Amplifier shown below -
Question 4:- If Length L1 of Mosfet M1 increases then total noise of amplifier shown below -
Question 5:- In Figure shown below Capacitor Cc is initially charge to 3V (polarity shown in figure), an input voltage pulse at time t=0 change from 0V to 3V , what will be the voltage at node Vx at time t = infinity ? Given Vt of M1 = 0.7V
a) b) c) d) e)
Question 6: When I reduce the length of M7 transistor then CMRR of OPAMP shown below -
a) b) c) d)
Question 8 :-
If in both case W/L of transistors are same then a) Rz1 > Rz2 b) Rz1 < Rz2 c) Rz1 = Rz2
a) b) c) d)
a) b) c) d)
gm1 * RL [gm1 + gmb] * [RL || r01] [gm1 + gmb + g01 ] * [RL || r01] gm1 * [RL || r01]
b)
c)
d)
Q 12 :- Feedback Circuit of Current Voltage feedback should have a) b) c) d) High Input Impedance , High Output Impedance High Input Impedance , Low Output Impedance Low Input Impedance , High Output Impedance Low Input Impedance , Low Output Impedance
Q 13: - Total Input & Output Impedance of a current amplifier is __________ & _________ when we put it into current - current feedback circuit. a) b) c) d) Increase , Increase Increase , Decrease Decrease, Increase Decrease , Decrease
Then Match the following K1 = K3 = 0 K1 = K2 = 0 K2 = K3 = 0 K2 = 0 High Pass Notch (Band eliminate) Low Pass Band Pass