Professional Documents
Culture Documents
External Antenna Tutorial
External Antenna Tutorial
X
How to use an
external
Antenna
www.tigal.com
www.tigal.com
Table of Contents
What you need ................................................................................................................................................. 3
Soldering iron ............................................................................................................................................. 3
Antenna Adapter ........................................................................................................................................ 3
Antenna...................................................................................................................................................... 3
Pandaboard ...................................................................................................................................................... 4
Pandaboard ES ................................................................................................................................................ 5
How to get support .......................................................................................................................................... 6
Pandaboard Rev.X
www.tigal.com
If you want to learn how to solder there are many tutorials online.
I recommend this one here: http://www.infidigm.net/articles/solder/
Antenna Adapter
1x U.FL-RPSMA Cable
Adapter cable from U.FL to RS-SMA Female with RG178 type cable, 15cm lenght
Antenna
1x VTWFA-3 RP/SW
Rubber antenna 2400MHz, 3dB gain, VSWR 1.6, RP-SMA Swivel connector
Pandaboard Rev.X
www.tigal.com
Pandaboard
Remove R20 (1) to disconnect the on-board antenna (2) so you can connect an external antenna directly to
the wireless chip (3) using a U.FL pigtail.
You can also use J5 and mount a different connector. For this place the resistor sitting on R20
to R18.
Pandaboard Rev.X
www.tigal.com
Pandaboard ES
The pandaboard has to be modified in the same manner except R20 and R18 are R14 and R15 respectively.
Remove R14 (1) to disconnect the on-board antenna (2) so you can connect an external antenna directly to
the wireless chip (3) using a U.FL pigtail.
You can also use J5 and mount a different connector. For this place the resistor sitting on R14
to R15.
Pandaboard Rev.X
www.tigal.com
TIGAL KG assumes no responsibility for any errors, which may appear in this manual. Furthermore, TIGAL KG reserves
the right to alter the hardware, software, and/or specifications detailed herein at any time without notice, and does not
make any commitment to update the information contained herein. TIGAL KG products are not authorized for use as
critical components in life support devices or systems.
Pandaboard Rev.X