You are on page 1of 1

DVR Board Common Problems and Solutions

USB interface undetectable


1, USB1.1 interface is not detected a: check whether the 5V power supply abnormalities, such as abnormal , see specific veneer repair work instructions ; b: Check the bus termination resistor and the interface is connected properly, the resistance value is normal, if the resistance value of the exception can be replaced ; 2, USB OTG interface is not detected , the fault indicator LED1 light a: 24M crystal is damaged, and if so, can replace , or 5V power anomalies , see specific veneer repair work instructions ; b: Check the bus termination resistor and the interface is connected properly, the resistance value is normal, if the resistance value of the exception can be replaced ; c: 3526 chip is damaged, you can replace ;

www.ttbvision.com

You might also like