Professional Documents
Culture Documents
Conduct Experiment On Lathe
Conduct Experiment On Lathe
.Tech Degree Practical Examinations Oct / Nov 2012 ME 2207 Manufacturing Technology I B.E Mechanical Engineering Regulations - 2008 Time: 3 Hours 1 Conduct experiment on Lathe Maximum Marks: 100 100
All dimensions are in mm Conduct experiment on Lathe. Single start thread cutting
100
All dimensions are in mm Prepare specimens and weld as shown in figure. Welding
100
(i)Draw gas cutting torch and mention various parts. (ii) conduct experiment on Butt welding of two plates of size 60 x 40 x 5 mm Fabricate a funnel as given in the diagram.
100
100
100
Fabricate a tray as shown below.(Thickness 1mm and all dimensions are in mm)
100
100
100
10
100
11
.(i) Explain Tailstock set over method. (ii) (ii)Conduct experiment of Internal boring in Lathe
20 80
12
(i)
20
80
13 14
Prepare mould for straight pipe with core. (i) explain overhead welding and safety requirements. (ii) Using gas cutting machine cut a circular plate of diameter 300mm with thickness 3mm. (i) Write the funcion of core and draw various types of Core. (ii) Prepare mould for solid cube.
100 20 80 20 80 100
15
16
17
Fabricate a funnel as shown below. (outer diameter is 40mm and inner diameter is 20mm with thickness 1mm)
100
40
40
18 19
Prepare a mould for loose piece pattern. (i) What is known as Brazing and explain with suitable example. (ii) Using gas cutting machine cut a square plate of 300mm side with thickness of 3mm. (i) Explain stack moulding with suitable sketches. (ii) Using a Lathe drill a through hole of diameter 25mm and turn outer diameter to 40mm with a width of 40mm.
100 20 80 20 80
20