Professional Documents
Culture Documents
Tl-Wa7510n v1 User Guide
Tl-Wa7510n v1 User Guide
FCC STATEMENT
This equipment has been tested and found to comply with the limits for a Class B digital device, pursuant to part 15 of the FCC Rules. These limits are designed to provide reasonable protection against harmful interference in a residential installation. This equipment generates uses and can radiate radio frequency energy and, if not installed and used in accordance with the instructions, may cause harmful interference to radio communications. However, there is no guarantee that interference will not occur in a particular installation. If this equipment does cause harmful interference to radio or television reception, which can be determined by turning the equipment off and on, the user is encouraged to try to correct the interference by one or more of the following measures: Reorient or relocate the receiving antenna. Increase the separation between the equipment and receiver. Connect the equipment into an outlet on a circuit different from that to which the receiver is connected. Consult the dealer or an experienced radio/ TV technician for help.
This device complies with part 15 of the FCC Rules. Operation is subject to the following two conditions: 1) 2) This device may not cause harmful interference. This device must accept any interference received, including interference that may cause undesired operation.
Any changes or modifications not expressly approved by the party responsible for compliance could void the users authority to operate the equipment. Note: The manufacturer is not responsible for any radio or TV interference caused by unauthorized modifications to this equipment. Such modifications could void the users authority to operate the equipment.
CE Mark Warning
This is a class B product. In a domestic environment, this product may cause radio interference, in which case the user may be required to take adequate measures.
DECLARATION OF CONFORMITY
For the following equipment: Product Description: 5GHz 150Mbps Outdoor Wireless Access Point Model No.: TL-WA7510N Trademark: TP-LINK We declare under our own responsibility that the above products satisfy all the technical regulations applicable to the product within the scope of Council Directives: Directives 1999/5/EC The above product is in conformity with the following standards or other normative documents ETSI EN 300 328 V1.7.1: 2006 ETSI EN 301 489-1 V1.8.1:2008& ETSI EN 301 489-17 V2.1.1:2009 EN60950-1:2006 Recommendation 1999/519/EC EN62311:2008 Directives 2004/108/EC The above product is in conformity with the following standards or other normative documents EN 55022:2006 +A1:2007 EN 55024:1998+A1:2001+A2:2003 EN 61000-3-2:2006 EN 61000-3-3:1995+A1:2001+A2:2005 Directives 2006/95/EC The above product is in conformity with the following standards or other normative documents EN60950-1:2006 DirectiveErP 2009/125/EC Audio/Video, information and communication technology equipment- Environmentally conscious design EN62075:2008 Person is responsible for marking this declaration:
TP-LINK TECHNOLOGIES CO., LTD. South Building, No.5 Keyuan Road, Central Zone, Science & Technology Park, Nanshan, Shenzhen, P. R. China
CONTENTS
Package Contents ....................................................................................................1 Chapter 1
1.1 1.2 1.3 1.4
Introduction.........................................................................................2
Product Overview ............................................................................................ 2 Conventions .................................................................................................... 2 Main Features ................................................................................................. 2 Panel Layout ................................................................................................... 3
1.4.1 1.4.2 The Rear Panel ...............................................................................................3 The Front Panel...............................................................................................4
Chapter 2
2.1 2.2 2.3
Chapter 3
3.1 3.2
Chapter 4
4.1 4.2 4.3 4.4 4.5 4.6 4.7
Antenna Alignment ....................................................................................... 59 Distance Settings.......................................................................................... 59 Throughput Monitor ...................................................................................... 60 Wireless Statistics ........................................................................................ 60
4.8
DHCP ............................................................................................................ 61
4.8.1 4.8.2 4.8.3 DHCP Settings ............................................................................................. 62 DHCP Clients List......................................................................................... 63 Address Reservation .................................................................................... 63
4.9
System Tools................................................................................................. 65
4.9.1 4.9.2 4.9.3 4.9.4 4.9.5 4.9.6 4.9.7 4.9.8 4.9.9 SNMP ........................................................................................................... 65 Diagnostic ..................................................................................................... 67 Ping Watch Dog............................................................................................ 68 Speed Test ................................................................................................... 69 Firmware Upgrade........................................................................................ 70 Factory Defaults ........................................................................................... 71 Backup & Restore......................................................................................... 72 Reboot .......................................................................................................... 72 Password ...................................................................................................... 73
Chapter 5
5.1 5.2 5.3 5.4 5.5 5.6
5.7
Wireless......................................................................................................... 97
5.7.1 5.7.2 5.7.3 5.7.4 5.7.5 Wireless Settings.......................................................................................... 97 Wireless Security ........................................................................................ 103 Wireless MAC Filtering ............................................................................... 105 Wireless Advanced..................................................................................... 108 Antenna Alignment ..................................................................................... 109
II
Distance Settings........................................................................................ 110 Throughput Monitor .................................................................................... 110 Wireless Statistics ...................................................................................... 111
5.8
5.9
5.11 Parental Control .......................................................................................... 128 5.12 Access Control ............................................................................................ 130
5.12.1 Rule ............................................................................................................ 130 5.12.2 Host ............................................................................................................ 132 5.12.3 Target ......................................................................................................... 133 5.12.4 Schedule..................................................................................................... 134
5.13 Static Routing .............................................................................................. 136 5.14 Bandwidth Control ....................................................................................... 137
5.14.1 Control Settings .......................................................................................... 137 5.14.2 Rules List .................................................................................................... 138
III
5.17.5 Backup & Restore....................................................................................... 149 5.17.6 Reboot ........................................................................................................ 149 5.17.7 Password .................................................................................................... 150 5.17.8 System log .................................................................................................. 151 5.17.9 Statistics ..................................................................................................... 153
Appendix A: FAQ..................................................................................................155 Appendix B: Factory Defaults .............................................................................160 Appendix C: Specifications .................................................................................161 Appendix D: Glossary ..........................................................................................162
IV
TL-WA7510N
Package Contents
The following items should be found in your package: One TL-WA7510N 5GHz 150Mbps Outdoor Wireless Access Point One Power Injector Ethernet Cable One Power Adapter for TL-WA7510N 5GHz 150Mbps Outdoor Wireless Access Point Mounting Kits Quick Installation Guide One Resource CD for TL-WA7510N 5GHz 150Mbps Outdoor Wireless Access Point, including: This User Guide Other helpful information