Professional Documents
Culture Documents
Stream Setup
Enabled Lines: Remote Stream Select: Enabled Line 1: Line 2: Line 3: CN WAD CN(T)
(Next ...) Flushing: Measurement Cell Flushing: Flushes between Stream: Same Stream Flushes: Filter Flushing: Measuring Cycles:
3 1
Note: 0 = OFF
(Next ...) Filtrate Bypass Normal Bypass (s) 0 0 0 After Filter Flushing (s): 0 0 0
1: 2: 3:
0 0 0 0 0
0 0 0 0 0
Trends
Timers
Timers 1 Min Cycle time: WAD Cycle: Titration Cycle: Auto Reset: Max Filling Time: 0 0 0 1 300 min s (0) s (0) min s
(Next ...) Timers 2 Time to Temp SP: Settle Time: Meas Time: Drain Time Level Sensor:
300 5 60 10 0
s s s s
(Next ...) Timers 3: Filter Flush: Auto Clean: Pre-Fill Bypass: Clean Time: Stripping
0 24 5 120 0
s h s s
(Next ...) Timers 4: LEX Dosing: AUX Dosing LEX Reaction: AUX Reaction: AgNO3 Reaction:
5 0 3 0 10000
s s s s ms
Calibration:
Calibration 1 m: c: 59.45 -483.73
NACN Calibration
(Next ...) Titration 1 Cell Volume Cycle Volume AgNO3 Staich Factor K
litre ml mol/litre
(Next ...) Titration 2 End Point Gradient End Point Counts Maximum Cycles
25 -900 200
Temperature
(Settings ...) Temperature Settings Temp Setpoint: Temperature Compensation Term A Term B Term C 25 0.000131 0.012494 0.605773
Cleaning
(Settings ...) General Cleaning Settings: Cleaning Time: H2O2 and HCL Cleaning Enable Auto Clean: Clean Interval: Post Clean Measure: 120
24 3
hours
(Next ...) HCL Flushing Stripping Time: Measuring Cycles: Post Clean Measure: Post Clean Flushing Reverse Current
0 0 3 3
s Note: 0 = OFF
Dosing
(Settings ...) LEX Dosing LEX Dilution Factor: Factor usage 0.977
None: CNWAD:
Dosing
1 x Dilute
n x Dilute
(Next ...) Aux Dosing- Continued Dose Times Line 1: 0 Line 2: 0 Line 3: 0
(Next ...) AgNO3 Dosing Pump Usage: AUX Pump LEX Pump
Current Loops
Output Assignments: CN Line 1: 1 Line 2: 2 Line 3: 0 WAD 5 6 0 CN(T) 0 0 0 pH 3 4 0
Tuning-4mA Tuning-20mA 6 260 31 240 6 260 31 240 6 270 31 240 6 260 31 240
Tuning-4mA Tuning-20mA 6 260 31 240 6 260 31 240 6 260 31 240 6 260 31 240
SMS
Enabled
pH
(Settings ...) pH Measure in last flush: Measuring Time:
10
Filters
Filter Times (s): Counts: pH: Filtrate Temperature: 2 2 1
Faults
Faults: Enabled Hose burst detection: Leak detection: Signal Relays: NO: NC:
About Cynoprobe
Panel Version: PLC Version: 3.02.11 3.02.11
(Setup ...) Cynoprobe Setup 2nd Line: 3rd Line: WAD Unit: Titration Unit