3. Draw a center point circle starting at the origin. Dimension the diameter to 0.468 inches. Draw a rectangle that is tangent to the right side of the circle and dimension the rectangle 0.041 inches wide by 0.051 inches tall. (center the rectangle on the x-axis.)
To center the rectangle on the x-axis draw a line on the x-axis and dimension from either end of the rectangle to the line half the vertical distance or 0.051/2 = 0.255 inches.
Continued next page
4. Draw the sketch show below:
Continued next page 5. Use the trim command to remove the parts of the drawing to it looks like the sketch below.
6. Use the fillet tool set to 0.125 inches to fillet the intersection of the large circle and the rectangle.
7. Use the 2D fillet tool set to 0.063 and fillet the four corners.
8. Draw a rectangle centered at the origin and dimension it 1.337 inches wide by 0.630 inches tall. Draw a center point circle centered at the origin and dimension it to a diameter of 0.465 inches. Trim the intersection of the circle and the rectangle. Fillet all of the intersections of the circle and the rectangle to 0.125 inches. Fillet the corners of the rectangle to 0.630 inches.