TL-R402M admin admin TD-8800 admin TL-WR642G admin admin TL-R460 admin admin TD-8810 admin admin TL-WR642Gv2 admin admin TL-WR641G admin admin TL-WR541Gv2 admin admin TL-WR542Gv2 admin admin TL-WR542Gv3 admin admin TL-WR541Gv3 admin admin TD-W9810G admin admin TL-WR541G admin admin TD-W8920G admin admin TD-8840 admin admin TL-WR340G admin admin TD-W890iG admin admin TL-R460v2 admin admin TD-W8960N admin admin TD-8816 admin admin TL-WR340Gv2 admin admin TL-WR340GD admin admin TL-WR841N admin admin TL-WR841ND admin admin TL-WR1043ND_DDWRTv24SP2 root admin TD-W8901G admin admin TD-8961ND admin admin TL-WR740N admin admin TD-W8951ND admin admin TD-8616 admin admin TD-8817 admin admin TD-W8910G admin admin TD-W8961NT admin admin TL-MR3220 admin admin TL-MR3240 admin admin TL-MR3420 admin admin TL-WDR4300 admin admin TL-WR1043N admin admin TL-WR1043ND admin admin TL-WR2543ND admin admin TL-WR542G admin admin TL-WR741N admin admin TL-WR741ND admin admin TL-WR940N admin admin TD-W8950ND admin admin TL-WR720N admin admin TD-W8960NB admin admin TD-W8960Nv1.3.6 admin admin TD-W8980 admin admin TL-WR740ND admin admin The default login username and password both are admin, if you or some one else changed them but you can not remember now, you need do the hard reset to restore the device to factory default settings. Note: A hard reset will remove all your settings, and your device will be restored to factory default settings. Do not perform a hard reset unless you have backed up your settings or you can do the configuration again. Method 1: Directly press and hold the reset button on the rear panel with a pin for approximately 6 to 10 seconds when the device is running, then the device will be reset and reboot automatically. Please check the Appendix to know which model can be reset by method 1, if you cant reset the device by following Method 1, please try method 2. Method 2: Step 1 Turn off the router (pull the power out of the unit). Step 2 Press and hold the reset button on the rear panel with a pin, while holding down the reset button turn on the router (plug the power back into the unit), and please continue holding down the reset button for approximately 15 seconds.
Step 3 Release the reset button and wait for the device to reboot. Note: 1. Make sure the device is powered on before it reboots completely. 2. After the hard reset, the IP address of the device should be change to the default192.168.1.1, and the default login username and password are both admin (all lower case). 3. Ensure that the IP address of your computer is in the same IP range with the device. That means your computer should have an IP address like 192.168.1.X (X is in range of 2~253), and the subnet mask is 255.255.255.0, the default gateway should be 192.168.1.1 which is the IP address of the device. Appendix: The devices with the specific hardware version and firmware version which listed below can be reset by following method 1. Others, or the hardware and firmware version of which wasnt listed should be reset by following method 2.