This document describes an 8 channel relay board that can be used to control devices requiring up to 24VDC or 240VAC power. Each of the 8 relays is rated for switching 24VDC/15A or 240VAC/10A loads and has an LED to indicate operation. The board requires a 24VDC power supply drawing a minimum of 300mA and includes the board, flat cable, and connector. Specifications provide details on the relay ratings and dimensions are given for the board. A circuit diagram and example project are also included.
This document describes an 8 channel relay board that can be used to control devices requiring up to 24VDC or 240VAC power. Each of the 8 relays is rated for switching 24VDC/15A or 240VAC/10A loads and has an LED to indicate operation. The board requires a 24VDC power supply drawing a minimum of 300mA and includes the board, flat cable, and connector. Specifications provide details on the relay ratings and dimensions are given for the board. A circuit diagram and example project are also included.
This document describes an 8 channel relay board that can be used to control devices requiring up to 24VDC or 240VAC power. Each of the 8 relays is rated for switching 24VDC/15A or 240VAC/10A loads and has an LED to indicate operation. The board requires a 24VDC power supply drawing a minimum of 300mA and includes the board, flat cable, and connector. Specifications provide details on the relay ratings and dimensions are given for the board. A circuit diagram and example project are also included.
24V Description : I have developped this board because I needed such a board to operate a microwave pop-corn oven and a couple of DC motors in vending machine. There are 8 relays each capable of switching 24VDC/15A or 240VAC/10A. Each relay has an LED to indicate when it is operated. The required power is 24V DC / minimum 300 mA. The set including : - One assembled and tested relay's board - One 10 PIN flat cable (approximately length 30cm) - One additional 10 PIN connector (c) Sigma-Shop.com All rights reserved. Specifications : Relays has Normally Open (NO) and Normally Closed (NC) Contacts rated for voltages: - 12VDC/15A - 24VDC/15A - 125VAC/15A - 250VAC/10A Relay's datasheed : (relays used : RAS-2415 - 1C) http://www.sigma-shop.com/information/Relay/RAS.pdf Supply : 24 Volts / 300mA Dimension : 120mm / 80mm / 20mm Connect power (24V) to board. Connect device who you like to control : GND +24V (c) Sigma-Shop.com All rights reserved. This is a scheme of one relay module (channel): Here is a sample project of Atmel application - board connected to AVR project controlled via USB: +24V 0-12V or 0-24V