SERIES 60 SERVICE MANUAL: 1-157b install an oversize oil seal and sleeve. Rear crankshaft oil seal installations only, install spacer and J 35686-11, to the center screw of the base.
SERIES 60 SERVICE MANUAL: 1-157b install an oversize oil seal and sleeve. Rear crankshaft oil seal installations only, install spacer and J 35686-11, to the center screw of the base.
SERIES 60 SERVICE MANUAL: 1-157b install an oversize oil seal and sleeve. Rear crankshaft oil seal installations only, install spacer and J 35686-11, to the center screw of the base.
6SE483 9610 1996 DETROIT DIESEL CORPORATION From Bulletin 6-60-98 1-157b Install an oversize oil seal and sleeve, as follows: 1. Install the new, oversize oil seal and wear sleeve assembly to the housing. NOTE: The assembly used in dry flywheel housings has a unidirectional, laydown type Teflon inner sealing lip and a forward facing Teflon dust lip. The assembly used in wet flywheel housings has a double-lip seal with unidirectional inner and outer laydown type Teflon sealing lips. 2. Add new adapter ring and spacers. Do not separate the two. Perform the following steps to install the rear oil sleeve: NOTE: The assembly used in dry flywheel housing has unidirectional, lip type Teflon inner sealing lip and a forward facing Teflon dust lip. The assembly used in wet flywheel housings has a double-lip seal with unidirectional inner and outer laydown type Teflon sealing lips. 1. Install the two guide studs, J 35686-2 , through the holes provided in the base, J 35686-1 , and into two of the tapped holes in the crankshaft, 180 apart. See Figure 1-130. Tighten the guide studs using the appropriate wrench on the flats of the studs. The base must be tight against the end of the crankshaft. Figure 1-129 Rear Oil Seal Installation 1.8 CRANKSHAFT OIL SEALS All information subject to change without notice. 1-157c From Bulletin 6-60-98 6SE483 9610 1996 DETROIT DIESEL CORPORATION 2. For rear crankshaft oil seal installations only, install spacer and J 35686-11 , to the center screw of the base. See Figure 1-130 and see Figure 1-131. Figure 1-130 Rear Oil Seal Installation 3. Install the rear housing and adapter ring with seal and sleeve assembly in place on the guide studs. See Figure 1-131. Figure 1-131 Rear Oil Seal and Sleeve Installation