Professional Documents
Culture Documents
Structural Section Tables (SST)
Structural Section Tables (SST)
Version 9.2
Canadian Institute of Steel Construction (CISC)
INTRODUCTION
The Structural Section Tables, version 9.2, contain the North American database of
structural steel sections listed in the CISC Handbook of Steel Construction, 9 th
Edition All dimensions and properties are given in Metric units only
Edition.
only, with the
exception of the section designation, nominal depth and nominal mass, which are
also given in Imperial units.
Further information on the properties and dimensions contained in this database
may be found in Part 6 of the CISC Handbook of Steel Construction, 9 th Edition.
This spreadsheet is protected and its contents cannot be altered. In order to
work with the database, the cell data must be copied and pasted into another
spreadsheet. This may be done by pressing Ctrl-A to select an entire worksheet,
Ctrl-C to copy, and Ctrl-V to paste into a blank worksheet.
Although no effort has been spared in an attempt to ensure that the numerical
values in this database are accurate to a degree consistent with current
structural design practice, the Canadian Institute of Steel Construction does
not assume responsibility for errors or oversights resulting from the use of the
information contained herein. Anyone making use of the contents of this database
assumes all liability arising from such use.
Copyright 2007
Canadian Institute of Steel Construction
CONTENTS
The SST database contains the following structural steel sections:
SHAPE_ID
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
DESIGNATION
W
S
M
HP
WWF
C
MC
L
WT
WWT
2L
2L
2L
WRF
HS
HS
HS
SLB
HA
DESCRIPTION
Wide-flange shapes
S-shapes
M-shapes
HP-shapes
Welded wide-flange shapes
Channels
Miscellaneous channels
Single angles
T-shapes cut from W-shapes
T-shapes cut from WWF-shapes
Double angles - Short legs back-to-back
Double angles - Long legs back-to-back
Double angles - Equal legs back-to-back
Welded reduced-flange shapes
Hollow structural sections - Square - CSA G40.20/21
Hollow structural sections - Rectangular - CSA G40
G40.20/21
20/21
Hollow structural sections - Round - CSA G40.20/21
Super light beams
Hollow structural sections - Square - ASTM A500
20
21
HA
HA
DEFINITIONS
A
Avl
B
B1
B2
BetX
BT
BT1
BT2
C
Crt
Cw
D
Dn_i
Dnom
Dsg
Ds_i
DT
Grp
HW
Ix
Ixy
Iy
J
K
K1
Mass
Omeg
Prp
Qf
Qw
RI
Rmax
Rmin
RO
Rop
Rx
Rxp
Ry
Ryp
Ry0
Ry8
Ry10
Ry12
Ry16
Ry20
SA
Shp
Slp
Sx
Sx1
Sx2
Sy
Sw
T
TanA
Tdes
T1
T2
Use
W
Wn
Wt_i
X
Xo
Xop
Y
Yo
Yop
Yt
Zx
Zy
W-shapes highlighted in yellow are commonly used sizes and are generally readily available.
CHANGES IN SST VERSION 9
1.
2.