Chapter==Introduction Section==Why not let oil do all the hard work? _Status==0 _Order==130 Contents==<h1>Why not let oil do all the hard work?</h1> <br /> Why not let oil do all the hard work, when mounting and dismounting pressure joi nts, by using the SKF oil injection method.<br /> <br /> In former times, brute force and the strength to wield a big hammer was needed t o assemble components with a press fit, and sometimes a flame cutter to disassem ble them again. Today, life is made easier if designers have the forethought to incorporate the oil injection method and use suitable equipment from SKF. The co mponents just slide apart quickly without hardly lifting a finger, let alone a h ammer!