Professional Documents
Culture Documents
GPS Vehicle Tracker: (GPS+GSM+SMS/GPRS) User Manual (H06)
GPS Vehicle Tracker: (GPS+GSM+SMS/GPRS) User Manual (H06)
(GPS+GSM+SMS/GPRS)
User Manual
(H06)
Preface
Thank you for purchasing the tracker. This anual shows how to operate
the device smoothly and correctly. Make sure to read this manual carefully before
using this product.
2. Product accessories
GSM four frequency system global general;
built-in switching power supply, exceed wide voltage input range: 9-24 VDC;
built-in vibration sensor, realize intelligent vehicle theft;
support the original car security; can external relays, to realize the remote control vehicle fuel
and electricity;
can be set up a hotline number for SOS call the police and security alarm;
can be set up 10 vice number for receiving device returns information;
can external SOS alarm button for emergency calls for help;
can external microphone, to realize the remote voice surveillance function;
built-in backup battery, realize the illegal cut the line alarm;
can be two-way the intercom
1Red LEDPower / state
LED state
Meaning
Always light
Slow Flashing2 seconds light, 2seconds dark
Charging
Charge full
Dark
Low power/Shut
Working normally
dark
LED state
Meaning
GSM initialization
GSM working normally
Always light
Always dark
GSM no signal
LED state
Meaning
Always dark
GSM no signal
3.Appearance schemes
4.Preparation Installation
Tips:
4.2.Install
install the tracker is hidden installation, you'd better to install it with the help of professional
companies or workers authorized by the distributor. Please install it according to the following
instruction.
4.2.1. To avoid the thiefs destruction, the tracker should be installed in a hidden place.
4.2.2 Don't put the tracker together with the emission sources, such as the parking radar
system, alarms and other vehicle-carried communication terminals.
4.2.3You can fix the tracker with the cable tie, or glue it with wide strong sponge double-sided
tapes.
4.2.4 Because the tracker has GSM and GPS antenna inside, please make sure the reception
side of GPS is upward (facing the sky), and there is no metal shelter above the tracker.
4.2.5 Suggestions are as follow: a, Hidden area under the decoration board below the front
windshield or back windshield; b, Hidden area around the front panel (with a surface made of
non-metal materials);
Attention: If there is a metal insulation or a heating layer glued in the windshield, it will reduce the efficiency of
GPS signal reception, and the GPS cant work well, you need to find other places to install again.
Line
definition
color
Wiring instructions
sequence
1. 2
Horn
3. 4
3. 4
5. 6
7
8
MIC-,MIC+
SOS
MIC-,MIC+
GND
Off
power/oil
Original
Orange.orange
Docking horn
blackred
OrangeOrange
white
black
black
Orange.
10
V-
11
V+
blackthick
redthick
original provide power supply cord, red line power positive, the black line for power
negative; When installation, please choose to separate negative power grounding
wires or by iron, don't and other ground were answered
5.2 The original car security line (green line)
5.3 Broken oil electricity control line (yellow line) to pick up off the gas and electric
relay 86 feet (i.e. relay socket in the fine yellow line)
5.4 MIC line2pin
External microphones, realize voice surveillance function
5.5 SOS line2pin
External SOS switch button, used for emergency calls for help
6.1 language setting command : LE
(English model)
6.2 obtain the version number command : HGT
6.3 Restore the factory command:RST pls wait 3 minute.
6.4 APN settings command : APN: AA, XX, YY (AA is the operator, XX is user
name and YY is password)
Example:APN:cmnet,,,
6.5 IP settings command : IP: IP mode # IP address # port #
Example:IP:1#www.gps588.com#8169#
6.6 Product registration command :
ZC + password + # + phone number ( master number) + # + car station ID
Example: ZC000000 # 15888185569 # 13677198895
Note: Only after you registered successfully
6.7 Pair number set command :SPN + phone number #
Example: SPN13685456894 # 13688724474 # 1368529088 # 1358520647 #
6.8 delete the corresponding vice No.
Example: DSPN13685456894 #
6.9 delete all pair number
Example: DSPN
Reply: Delete all pair number success
6.10.query pair number
Example: FSPN
6.11 modify registration password
MP old password + new password,
Example: MP000000987654
6.12. fence set
multi-mode fence setting command : the fence code + radius +
fence mode Example: RCA999 # 1
Note:999 is fence radius;1 is fence number
fence mode is set separately
Example: RCMA1
6.13 clear fence instructions: DRC. Clear all fences
Special statement
1.the product have technology to change without prior notice
2.Product appearance and color is subject to change, in kind prevail.
3.Warranty card is only applicable to the IMEI number listed machines.
4.Please keep the card, show this card and the original purchase documents when
guarantee.
5The specific scope under warranty please see table explanation.
This card for the warranty certificate, please fill in this card and
save.
Name
Phone
Address
Model
IMEI NO.
Buying date
Invoice number
Sales
unit
name
Sales
address
unit