Professional Documents
Culture Documents
Table of contents
FRONT PANEL MACHINE CONTROL BUT TONS............. 1-3
EDIT DROP DOWN MENU ........................................... 3
TOOLS DROP DOWN MENU......................................... 4
TOOL POD DESIGNATIONS............................................ 6
RIGHT-CLICK MENU ....................................................... 6
MILL DROP DOWN MENU............................................ 7
QCJ5 SPINDLE HEIGHT REFERENCE.............................. 8
DIAGNOSTIC COMMANDS AND TECH SUPPORT.......... 9
NOTES.............................................................................. 10
Introduction:
The purpose of this quick reference manual is to explain the most
commonly used functions on the QCJ5 and IsoPro. This manual
will not serve as a replacement for the QCJ5 manual, more of a
supplement. This manual should be kept in close proximity to the
Machine for easy reference as to what each function indicates.
Mill Feed control box (available when Machine Jog dialogue is open):
Mill Feed Up will increase the cutting feed of the cutting tool
loaded in the spindle.
Mill Feed Down will decrease the cutting feed of a cutting tool
loaded in the spindle.
Jog Feed control box (available when Machine Jog dialogue is open):
Jog Feed Up will increase the jog speed of the Quick Circuit.
Jog Feed Down will decrease the jog speed of the Quick Circuit.
Home button:
Prior machine initialization, will initialize the Quick Circuit.
Once machine is initialize, will move machine to home position.
Pause button (activated only during milling cycle):
The Pause button will pause the Quick Circuit during a milling
cycle and open the machine jog dialogue.
Jog button (available only after initialization):
The Jog button will open and close the machine jog dialogue.
Directional Jogging (available when Machine Jog dialogue is open):
Note: Movement will be continuous or incremental according to jog
mode. (Continuous is default)
Jog Machine Back (+X)
Jog Machine Left (+Y )
Machine Right (-Y )
Jog Machine Forward (-X)
Jog
Allows for
ContactByTouch >
Options dialogue.
ContactByTouch >
Area (top layer).
ContactByTouch >
Reorder Entities - Tool used to reorder mill path. Use the feature
to reduce milling time.
Rubout - Removes all excess copper in defined area.
Snap To Objects - Snap new entities to an existing entity.
Snap To Grid - Snap new entities to a grid point.
Database Tool - Tool for efficient management of board material.
Placement
Tool
on
a
piece
Database Tool.
of
Allows
board
you
to
material
place
stored
in
circuit
the
Right-Click Menu
Right clicking in the main window and selecting the Machine
cursor menu gives you the following display.
Jump to Cursor Moves the head assembly to the current X,Y
position of the cursor.
Machine Net After right clicking on an entity, the machine mills all
entities contained in connected the net.
Test Depth of Cut Allows you to test the depth of cut of a pointed
milling tool. This feature is not available if the machine has not been
initialized.
Mill to End If you need to stop machining on a board before the
Information:
The Maximun Z Stroke positive extreme is the machines Z axis home postion
The Rapid Plane is set at a distance above (or below) the Material Height. The actual distance amount
is defined by the user. NOTE: The Rapid Plane is used to allow the QCJ5 to move at full traverse
down to the Rapid Plane, then slow down to the user-defined feed rate before entry into the material.
The Material Height is defined as the top of the work piece. NOTE: The Material Height must be defined
whenever material has been added, fiipped over, or adjusted in any way.
The Depth Of Cut is defined as the depth the tool will cut into the material.
The Plate Height is defined as the top of the QCJ5 Table Top. This also sets the Maximum Z Stroke length.
NOTE: This is set by the factory, and should not be adjusted.
Diagnostic commands :
notes
10