This document discusses measuring the sensitivity and selectivity of a radio receiver for the 88-108 MHz frequency band. It provides the measured values of gain limited sensitivity at -70dBm and output noise level at -17dBm. It also states that the level of a signal on a neighboring channel must be -56dBm to meet noise limited sensitivity requirements. The document asks for the measurement block diagram, procedures to measure selectivity, and an evaluation of noise limited sensitivity and selectivity to a neighboring channel.
This document discusses measuring the sensitivity and selectivity of a radio receiver for the 88-108 MHz frequency band. It provides the measured values of gain limited sensitivity at -70dBm and output noise level at -17dBm. It also states that the level of a signal on a neighboring channel must be -56dBm to meet noise limited sensitivity requirements. The document asks for the measurement block diagram, procedures to measure selectivity, and an evaluation of noise limited sensitivity and selectivity to a neighboring channel.
This document discusses measuring the sensitivity and selectivity of a radio receiver for the 88-108 MHz frequency band. It provides the measured values of gain limited sensitivity at -70dBm and output noise level at -17dBm. It also states that the level of a signal on a neighboring channel must be -56dBm to meet noise limited sensitivity requirements. The document asks for the measurement block diagram, procedures to measure selectivity, and an evaluation of noise limited sensitivity and selectivity to a neighboring channel.
for the 88-108 MHz frequency band. The specific block diagram is used for measuring the sensitivity and the selectivity. The measurements are performed by noticing the power level of the input and output signals.
The following values are obtained: gain
limited sensitivity: -70dBm, output noise level: -17dBm, the level of the signal on the frequency of the neighboring channel in order to fulfil the conditions from the measurement of the noise limited sensitivity: -56dBm.
16:20:28
SISTEME I Echipamente pentru Comunicaii Radio
You are required to:
1. Give the block diagram for performing the measurements; 2. Describe the procedures in order to measure the selectivity; 3. Evaluate the noise limited sensitivity and the selectivity to the neighboring (adjacent) channel.
16:20:28
SISTEME I Echipamente pentru Comunicaii Radio
fc=fm0 BPF 1 SSG
SDA
RRUT
R0 2 LPF ftfmM
16:20:28
SISTEME I Echipamente pentru Comunicaii Radio
3. a. Gain limited sensitivity:
Sa=-70dBm The standard power is measured: Po=50mW=16,9dBm So the maximum power gain is: Gp= Po/ Sa = 16,9-(-70)=86,9dB
16:20:28
SISTEME I Echipamente pentru Comunicaii Radio
3. a. The noise limited sensitivity is defined for a
SNR=26 dB; 4. Knowing Pz=-17dBm it results the signal power necessary in order to obtain this SNR: SNR=Ps/Pz so: Psz =Pz *SNR =-17+26=9dBm So the noise limited sensitivity is: Sz= Psz / Gp = 9-86,9=-77,9dBm 16:20:28
SISTEME I Echipamente pentru Comunicaii Radio
c. The level of the signal measured for the
neighboring channels is: Sp= -56dBm
The selectivity to the neighboring channel is:
aa= 10 log (Sp/Sz) So it is obtained: aa = -56dBm-(-77,9dBm)=21,9 dB 16:20:28