Professional Documents
Culture Documents
Data Book: Automotive Technical
Data Book: Automotive Technical
M3 & CAT
1987 to 1991
Engine &
Cooling
Fuel
Ignition
Electrical
Running
gear
Torque
settings
Capacities
Notes &
Illustrations
BMWP3102350
Automotive
Technical
DATA
BOOK
M3 & CAT
Type
Capacity (cm3) / number of cylinders
Compression ratio / pressure
Oil pressure
Oil temperature
Valve clearance - inlet
Valve clearance - exhaust
Firing order
No 1 cylinder position
Thermostat opening temperature
Radiator cap pressure
bar
bar
C
mm
mm
C
bar
M3 & CAT
rpm
rpm
%
ppm
%
%
bar
bar
RON
Ignition system
Type
Ignition coil
Primary resistance
Ballast resistor
Voltage - Tmnl 15(+) to earth
Distributor
Points gap (air gap)
Dwell angle
Condenser capacity
Rotation
Ignition timing - basic [static
V = Vacuum NV = No Vacuum
Total ignition advance
Centrifugal check.
ohms
ohms
V
mm
(%)
F
Crankshaft @ rpm
Crankshaft
Crankshaft
Crankshaft
Crankshaft
Crankshaft
Crankshaft
@ rpm
@ rpm
@ rpm
@ rpm
@ rpm
@ rpm
mbar
Crankshaft
mm
M3 & CAT
DME Motronic
Bosch 0 221 118 335
0.82
_
_
Bosch
[0.30 to 0.70]
_
_
_
Computer control
_
Computer control
_
_
Computer control
_
_
Computer control
_
Bosch/Champion
X5DTC / A6G
0.60 to 0.70
1987 to 1991
M3 & CAT
1987 to 1991
12 / 66Ah
13.5 to 14.2 / _ / 1500
160 / 9.0
_
Running gear
M3 & CAT
mm
mm
2.0
2.0
Size
Size
bar
bar
205/55x15
_
2.1 / 2.3
_
1
2
3
4
[+175]
-4230. E2: -5530
+9830. E2: +91830
+141130. E2: +142430
mm []
[+247]. 90 : [+287]
-22030
M3 & CAT
Nm
Nm
Nm
Nm
Nm
Nm
Nm
Nm
Nm
Nm
Nm
Nm
M3 & CAT
litres
litres
litres
litres
litres
litres
1
2
1987 to 1991
502
802
Wait 15 mins.
1002
10, 30 + 60+2 N
22.52.5 + 503
24. 10.9 hex: 35
113 to 130 N
290
195 to 210
81 to 90
24 to 28
Capacities
Engine oil & filter
Gearbox - 4-speed [5-speed]
Automatic transmission - refill
Final drive
Cooling system
Fuel tank
1987 to 1991
mm []
1987 to 1991
88050
_
1.00.5. CAT: 0.80.4
200
_
_
Bosch
DME-Motronic
_
_
3.00.06
98[R]2
Electrical system
Battery
V / CC / RC
Alternator voltage / full load current / engine rpm
Starter motor current / voltage - cranking
A/V
Starter motor current / voltage - locked
A/V
1987 to 1991
Fuel system
Idle speed - manual [auto]
Fast idle speed - manual [auto]
CO @ idle speed [3000 rpm] - see page VI
HC @ idle speed [3000 rpm] - see page VI
CO2 @ idle speed [3000 rpm] - see page VI
O2 @ idle speed [3000 rpm] - see page VI
Carburettor / fuel injection
Type / ref
Main jet / needle
Injection pressure
Pump pressure
Octane rating
HELP
4.4
1.5
_
1.7
9.0
55 or 70
1987 to 1991