P) FOR MILLING MACHINE CHECK THE MACHINE Check the machine to see if it is in good running order and properly lubricated, and that it moves freely.
SELECTING THE CUTTER
Select a lathe cutter of larger diameter than is necessary.
MOUNTING THE CUTTER AND TOOL HOLDER
Place the cutter on the tool holder as near the end of the MOUNTING THE WORKPIECE spindle as the work permits to machine prevent springing the jaw. Workpieces must be mounted properly and securely. Use the milling vise or another clamping devices that suitable with the workpiece. Feed the workpiece in a direction opposite the rotation of the milling cutter.
SETUP THE START LEVER AND SPINDLE SPEED
The starting lever and table control lever should all be in neutral and spindle speed control should be set to the required speed. START THE SPINDLE AND CUTTING FLUID PUMP To actuate spindle, turn on the main power first. Start the main motor and cutting fluid pump.
STOP THE SPINDLE
To stop the rotation, press the spindle stop button. Press the Emergency Stop Button only in case of emergency.