Professional Documents
Culture Documents
fica
de
Yucat
a
n
A.
C.,
intemperizados en suelos y sedimentos
3 Renewable Energy Unit; Calle 43 No. 130, Colonia Chuburn
a de Hidalgo, C.P. 97200, Merida, Yucatan, Mexico.
(Biodegradation modeling of sludge bioreactors of total petroleum hydrocarbons weathering in soil
and
sediments) August
Received
Abstract
259 Crecimiento,
sobrevivencia y adaptacin
de Bifidobacterium
infantis
a condiciones
cidasenvironmental
fertigation
indiscriminately,
however,
this wastewater
generates
serious
Keywords: energy crop, UASB treated vinasse, distillery wastewater management, soil fertility.
Resumen
271 Localizacin
de una o
planta
crticaindiscriminada,
y adecuacin de los
empleados
Las vinazas se han utilizado
en la fertirigaci
n deindustrial:
cultivosRevisin
de manera
sincriterios
embargo,
estasenaguas residuales
esta decisin
generan danos graves al medio
ambiente, desde la reduccion en el rendimiento o muerte de los cultivos a corto plazo, as
(Plant site
Critical review
and adequation
criteria
usedorg
in this
decision)
como la acidificacion, disminuci
on selection:
de la oxigenaci
on, aumento
de la
carga
anica,
acumulacion de fenoles en el suelo
J.R.
Medina,
R.L.
Romero
y
G.A.
Prez
en el mediano y largo plazo. El objetivo de este estudio fue la fertirrigacion de sorgo dulce (Sorgo bicolor L. Moench) en
laboratorio (bioensayos de germinacion) y crecimiento en vivero con vinazas tratadas de Etanol hidratado de un UASB
modificado, con la finalidad de mejorar sus propiedades qumicas y utilizarlas al 50, 75% (diluidas) y al 100 % de vinaza
tratada (TV50, TV75 y TV100 respectivamente). La vinaza cruda (RV) presento el porcentaje mas bajo de germinacion
en las semillas de sorgo dulce en las pruebas de laboratorio (14% en 8 das) comparado con el tratamiento control donde
germino el 94% de las semillas. El crecimiento de las plantulas en el vivero con la vinaza cruda (RV) fue menor que en
otros tratamientos, y despues de 13 das las plantas detuvieron completamente su crecimiento y murieron.
Palabras clave: cultivos energeticos, vinasas tratadas UASM, manejo de aguas residuales de destileras, fertilidad del suelo.
Introduction
713
Mijangos-Cortes et al./ Revista Mexicana de Ingeniera Qumica Vol. 13, No. 3 (2014) 713-722
714
2
2.1
2.2
Treated
vinasse,
characteristics
origin
and
www.rmiq.org
Mijangos-Cortes et al./ Revista Mexicana de Ingeniera Qumica Vol. 13, No. 3 (2014) 713-722
1
S (mg L )
1
SO2
4 (mg L )
+
1
K (mg L )
Untreated Vinasse
4.510.3
125,60013,000
1,377140
11360
14740
17235
5,433810
6,706930
Treated Vinasse
7.220.3
39,810630
1,16070
2300
11710
27517
00
6,838240
*The UASB reactor was managed following the procedure established by EspanaGamboa et al. (2012).
2.3
www.rmiq.org
715
Mijangos-Cortes et al./ Revista Mexicana de Ingeniera Qumica Vol. 13, No. 3 (2014) 713-722
2.4
3
3.1
716
100
80
Germination (%)
60
40
20
Control
TV50
TV75
TV100
RV
Time (d)
Figure 1. Percentage of germination of S. bicolor L. Moench var. M81E seeds imbedded for eight days in
www.rmiq.org
Mijangos-Cortes et al./ Revista Mexicana de Ingeniera Qumica Vol. 13, No. 3 (2014) 713-722
Table 2. Physiological germination seed indexes S. bicolor L. Moench var. M81E under the
effect of hydrated ethanol stillage in a UASB treated and untreated vinasse.
Index
GV
MDG
PE (d)
GF
Treatment
TV75
Control
TV50
23.671.52a
18.691.26ab
14.310.89bc
0.770.07
1c
9.040.79 a
0.4650.015
2b
5.640.23 b
0.4250.017
2b
50.25 b
TV100
RV
c
2.990.67 d
0.0180.006 d
8a
0.040.015 d
11.470.74
0.2650.005 c
2b
2.750. 13 c
GV, germination value; MDG, mean daily germination; PE, period of energy; GF, germinative force
(1 102 ). Values through lines with the same letters are statistically similar. PE is expressed in days.
Mean Std. error.
1.0
0.8
0.6
0.4
0.2
Control
TV50
TV75
TV100
RV
0.0
Time (d)
Figure 2.2.
Mean
daily germination
time of seeds of S. bicolor
L. Moench
var. M81E,
imbedded inof S.
Fig.
Mean
dailyovergermination
over
time
of seeds
untreated and treated vinasses in a UASB. Mean Std. error
bicolor
L. Moench var. M81E, imbedded in untreated
and treated vinasses in a UASB. Mean Std. error.
www.rmiq.org
717
Mijangos-Cortes et al./ Revista Mexicana de Ingeniera Qumica Vol. 13, No. 3 (2014) 713-722
3.2
www.rmiq.org
Mijangos-Cortes et al./ Revista Mexicana de Ingeniera Qumica Vol. 13, No. 3 (2014) 713-722
80
60
40
20
Control
TV50
TV75
TV100
RV
3.3
www.rmiq.org
719
Mijangos-Cortes et al./ Revista Mexicana de Ingeniera Qumica Vol. 13, No. 3 (2014) 713-722
Control
6.43
6.675
36.86
581.71
11.68
245.78
Silt loam
24.6
59.28
16.12
TV50
6.61
7.032
9.49
2397.06
11.42
367.23
Silt loam
22.04
58.56
19.4
TV75
6.97
7.033
12.46
2476.81
12.29
358.61
Silt loam
20.04
58.56
21.4
TV100
7.17
7.178
9.38
3344.66
9.95
505.16
Silt loam
20.04
54.56
25.4
Conclusions
This work suggests that vinasses treated by this
method can be used concentrated, so partly or
completely could replace the fresh water for Sweet
sorghum irrigation from which ethanol is obtained,
contributing to the sustainability of the bioethanol
production system.
The raw vinasse (RV) was deleterious for
germination (14% to 8 days) of sweet sorghum seeds
compared to the Control treatment where germinated
94% of seeds and a delay in germination time (6 days)
in the lab test. Growth of seedlings in nursery with
RV was lower, and after 13 days the plants completely
stopped growth and died.
www.rmiq.org
Mijangos-Cortes et al./ Revista Mexicana de Ingeniera Qumica Vol. 13, No. 3 (2014) 713-722
Acknowledgments
The authors gratefully acknowledge the contribution
of I.A.H. Daniel A. Leon Gomez for the technical
assistance in the nursery. This research was partially
financed by Fondo Sectorial CONACYT-CONAVI,
Scientific Project: No. 101284.
References
Ahmad, S., Ahmad, R., Ashraf, M., Ashraf, M.
and Waraich, E. (2009). Sunflower (Helianthus
annus L.) response to drought stress at
germination and seedling growth stages.
Pakistan Journal of Botany 41, 647-654.
Ali,
www.rmiq.org
721
Mijangos-Cortes et al./ Revista Mexicana de Ingeniera Qumica Vol. 13, No. 3 (2014) 713-722
722
www.rmiq.org