Professional Documents
Culture Documents
Tension Pneumothorax in The Perinatal/Pediatric Patient
Tension Pneumothorax in The Perinatal/Pediatric Patient
PERINATAL/PEDIATRIC PATIENT
by
COURSE DESCRIPTION
This Tension Pneumothorax course was designed for the Neonatal Intensive Care Respiratory
Therapist to provide an increased understanding of this possibly fatal occurrence. Recognition of
signs and symptoms, causes and prevention, complications, treatment, management and
monitoring of neonates at risk for or with the diagnosis of tension pneumothorax is the focus of
this module. With a more comprehensive knowledge, the Respiratory Therapist will be better
equipped when the probability of tension pneumothorax arises and, in addition, increase the
quality of care we provide these neonates.
BEHAVIORAL OBJECTIVES
UPON COMPLETION OF THE READING MATERIAL, THE PRACTITIONER WILL BE
ABLE TO:
1. Define tension pneumothorax.
2. List four other air leaks common in the neonate.
3. State why tension pneumothorax may be fatal.
4. List the etiology of tension pneumothorax.
5. Describe why cerebral hemorrhage can be a sequel of tension pneumothorax.
6. List the signs and symptoms of an infant with a pneumothorax.
7. Explain why it is difficult to palpate a deviated trachea on the newborn.
8. Explain why breath sounds are not the most reliable assessment tool in pneumothorax of the
infant.
9. Describe the most obvious clues in the assessment/diagnosis of tension pneumothorax in the
newborn.
10. Describe how to assess the point of maximal impulse (PMI).
11. Describe how to assess pulsus paradoxus.
12. Describe the features of a tension pneumothorax on neonatal CXR.
13. Describe how to identify a pneumothorax via transillumination.
14. Describe the procedure for needle decompression.
This material is copyrighted by RC Educational Consulting Services, Inc. Unauthorized duplication is prohibited by law.
This material is copyrighted by RC Educational Consulting Services, Inc. Unauthorized duplication is prohibited by law.
INTRODUCTION .............................................................................................................. 6
ETIOLOGY ........................................................................................................................ 7
CEREBRAL HEMORRHAGE, INTRACRANIAL HEMORRHAGE (ICH)
OR INTRAVENTRICULAR HEMORRHAGE (IVH)................................................. 8
DIAGNOSIS ....................................................................................................................... 8
PHYSICAL SYMPTOMS AND SIGNS....................................................................... 8
ASSESSMENT ................................................................................................................. 10
GENERAL ................................................................................................................. 10
ASSESSMENT OF THE POINT OF MAXIMAL IMPULSE (PMI) .................. 10
ASSESSMENT OF PULSUS PARADOXUS ...................................................... 10
CHEST X-RAY.......................................................................................................... 11
INDENTIFICATION OF TENSION PNEUMOTHORAX ON CXR ................. 11
TRANSILLUMINATION ......................................................................................... 12
INDENTIFICATION OF A TENSION PNEUMOTHORAX
WITH A TRANSILLUMINATOR....................................................................... 12
TREATMENT FOCUSES ON MANAGEMENT AND MONITORING....................... 12
TREATMENT ............................................................................................................. 12
NEEDLE DECOMPRESSION............................................................................. 13
CHEST TUBES..................................................................................................... 14
CHEST TUBE INSERTION............................................................................ 14
CONTINUOUS MONITORING ................................................................................................................... 16
MANAGEMENT.............................................................................................................. 16
PREVENTION.................................................................................................................. 16
This material is copyrighted by RC Educational Consulting Services, Inc. Unauthorized duplication is prohibited by law.
This material is copyrighted by RC Educational Consulting Services, Inc. Unauthorized duplication is prohibited by law.
INTRODUCTION
ormally on expiration, air is expelled from the lungs and the pleural space remains a
potential space (Fig. 1). With a tension pneumothorax, during inspiration, air leaks
through the affected parenchymal lesion into the pleural space. The tear in the pleura
acts as a one-way valve, impeding movement of the trapped air. As respiration continues, more
air is forced into the intrapleural space. This causes a shift of the thoracic contents and a kinking
of the greater blood vessels. This causes severe complications.
Figure 1
A pneumothorax is the most common of the air leaks that occur in newborns. Occurrence
statistics range from 1-10% of healthy, term neonates to 15-45% of ill mechanically ventilated
neonates. The incidence of air leaks is higher in newborns with respiratory distress syndrome
(RDS), meconium aspiration and transient tachypnea of the newborn (TTN or TTNB). Air leaks
include pneumomediastinum, pneumopericardium, pulmonary interstitial emphysema (PIE),
pneumothorax and pneumoperitoneum. Where the air accumulates after it leaks from the alveoli
determines what kind of air leak will develop.
Pneumothoraces are divided into two categories; open and tension. We will be discussing
tension pneumothorax.
In tension pneumothorax (Fig. 2), the intrathoracic pressure changes induced by increasing
pleural space volumes can affect the entire chest. Initially, increased pressure adversely affects
the ipsilateral (meaning affecting the same side of the body), then contralateral (meaning
affecting the opposite side of the body) lung volumes and gas exchange. Increasing mediastinal
pressure may distort the caval (vena-cava)-strial (band of tissue) juncture and impede blood flow
or compresses mediastinal venous structures, thereby decreasing venous return to the heart and
subsequent cardiac output. In other words, a tension pneumothorax has profound affects on all
the structures in the thoracic cavity.
This material is copyrighted by RC Educational Consulting Services, Inc. Unauthorized duplication is prohibited by law.
ETIOLOGY
ll perinatal/pediatric air leaks usually develop from a common event. The initial event is
generally a rupture of the alveoli, usually secondary to uneven aeration in the alveoli.
The pediatric/perinatal patient who fits any of these listed situations should be monitored
closely for the development of a pneumothorax:
Stiff lungs with low compliance
Hyperinflated lungs
Pneumonia due to mucus plugs and consolidation, which may bring about uneven
aeration of the alveoli.
Iatrogenic causes
This material is copyrighted by RC Educational Consulting Services, Inc. Unauthorized duplication is prohibited by law.
When there is a sudden rise in cerebral capillary pressure, as a result of a pneumothorax, cerebral
hemorrhage can occur. Intrathoracic pressure increases with a pneumothorax. This causes the
decrease of venous blood returning to the right atrium, which can lead to over perfusion of the
periventricular cerebral circulation. Due to the fragility of capillaries in the premature infant and
autoregulatory mechanisms, which control vascular tone being immature, capillaries can rupture
easily. A pneumothorax accelerates this process by suddenly and dramatically increasing
intrathoracic pressure.
DIAGNOSIS
PHYSICAL SYMPTOMS AND SIGNS
Vital signs:
Increasing systolic blood pressure above baseline
Hypotension
Increasing heart rate above baseline
Increasing pulse pressure above baseline
This material is copyrighted by RC Educational Consulting Services, Inc. Unauthorized duplication is prohibited by law.
Gradual or very rapid deterioration (depending on the severity of the air leak)
Unusual irritability
Restlessness
Cyanosis
Periods of apnea
PMI movement from the original location of the point of maximal impulse
In the newborn, its size makes it almost impossible to palpate a deviated trachea.
Sounds are easily transmitted through the infants chest, so it is difficult to assess
breath sounds or the absence thereof.
Chest pain
This material is copyrighted by RC Educational Consulting Services, Inc. Unauthorized duplication is prohibited by law.
ASSESSMENT
GENERAL
Severe hypoxemia
Tachycardia/bradycardia
Diminished intensity or altered pitch of breath sounds on the side of the injury,
particularly evident during positive pressure ventilation (PPV).
Profound hypotension
Inflated hemithorax with reduced thoracic excursion noted on the affected side.
This material is copyrighted by RC Educational Consulting Services, Inc. Unauthorized duplication is prohibited by law.
10
CHEST X-RAY
Identification of Tension Pneumothorax on CXR
Displaced
Mediastinum
Area Of Black/Absence
of Lung Markings
Depressed Diaphragm
Collapsed Lung
AP View
Chest x-rays should be taken during expiration in both anteroposterior and lateral views.
A pneumothorax is identified on the chest x-ray as an area of black, without vascular markings,
indicating air that surrounds the collapsed lung. To differentiate between a pneumothorax and a
skin fold, look for lung markings in the air filled space and the edge of the lung. If lung
markings are absent, it is a pneumothorax. Although skin folds may appear as the border of the
lung, the space surrounding the line will have lung markings, which is inconsistent with a
pneumothorax. The skin fold may also be seen beyond the confines of the pleural cavity and into
the soft tissues of the chest wall. In a tension pneumothorax, the diaphragm on the effected side
will be depressed and the intercostal spaces will be widened. The mediastinum may also be
displaced away from the pneumothorax. If the air is under sufficient pressure to shift the lung
and mediastinal structures to the opposite side it is called a tension pneumothorax.
This material is copyrighted by RC Educational Consulting Services, Inc. Unauthorized duplication is prohibited by law.
11
TRANSILLUMINATION
Identification of a Tension Pneumothorax with a Transilluminator
Transillumination showing a normal
pattern of reflected light on the surface
of the thorax.
Transillumination to identify air leak in the newborn has been used as a diagnostic tool for at
least 15 years. Following the clinical signs and symptoms of a pneumothorax, transillumination
should be the next step in diagnosing the neonate.
Transillumination is done with a high-intensity light source, usually fiberoptic, on the thoracic
surface. When the light is placed against the thorax of a neonate with normal lungs, the light is
reflected to the surface of the thorax by the lung tissue, forming a uniform circle around the light.
In the presence of free air in the thorax, the light is reflected at odd angles due to the collapse of
the lung. The result is an irregular-shaped reflection in the chest wall, with fingers of light
possibly appearing away from the light source (Fig. 3). It is best to darken the room as much as
possible and position the light perpendicular to the chest. Avoid tape and change the location of
chest leads, which obscure the light beam, to the shoulder. Gross edema of the chest wall can
lead to a false negative. A negative transillumination does not rule out a pneumothorax. Hourly
transillumination of the high-risk neonates as a monitoring tool is common in the Neonatal
Intensive Care Unit.
TREATMENT FOCUSES ON MANAGEMENT AND MONITORING
TREATMENT
reatment depends on the severity of the newborns symptoms. The infant in severe
distress should have the trapped air removed through needle aspiration. This is an
emergency procedure to be used until a chest tube can be inserted. Needle decompression
should even precede confirmatory chest x-ray if signs of respiratory distress or shock are present,
as without this procedure, the tension pneumothorax could be fatal.
This material is copyrighted by RC Educational Consulting Services, Inc. Unauthorized duplication is prohibited by law.
12
Needle Decompression
Figure 4
Needle decompression creates an open pneumothorax, equilibrating the affected side to the
atmosphere and providing a temporary reduction in thoracic pressure.
Insert an over the needle catheter, 18-20 (23-25) gauge. Some references state that the
puncture be made through the second intercostal space on the midclavicular line, just
above the third rib. The Pediatric Advanced Life Support (PALS) recommendation, and
ours, is the third intercostal space in the anterior axillary line (Fig. 4).
Positions for needling chest for pneumothorax and for chest tube position:
This material is copyrighted by RC Educational Consulting Services, Inc. Unauthorized duplication is prohibited by law.
13
CHEST TUBES
Chest Tube Insertion
Figure 5
Standard sharp and blunt surgical dissection is the preferred insertion method in the neonate. To
remove air, the tube is usually placed high in the chest in the second or third intercostal space in
the midclavicular line, but it may also be placed laterally (Fig. 5).
A chest tube should be attached to a one-way valve, water seal or suction. Suction level should
range from 15 cmH2 O for small leaks to 25 cmH2 O for larger.
Chest tubes can be removed when the patients respiratory distress is resolved, there has been no
leakage from the tube for 24 to 48 hours and the extrapulmonary air has been resolved for 24-48
hours. Often, the tube is clamped for 24 hours before removal to assure complete resolution of
the air leak.
Obtain a chest X-ray to assure proper placement and air evacuation.
Assess the drainage system in a systematic way:
This material is copyrighted by RC Educational Consulting Services, Inc. Unauthorized duplication is prohibited by law.
14
Clamp only to simulate tube removal to determine patient tolerance for 12-24
hours before anticipated removal and obtain a chest x-ray just prior to removing
the tube.
Monitor the collection chamber for the rate and nature of drainage.
There is minimal drainage expected with pneumothorax.
Water level:
This reflects actual pressure changes in the pleural space.
If there is no vigorous bubbling, water movement with respirations should be
visible. Spontaneous respirations water should move up the column with
inspiration on exhalation, the water should go back down to baseline.
Positive pressure ventilation should be just the opposite. These water movements are
called tiding. Tiding may be damped in patients on PEEP and those whose lungs are
fully re-expanded.
Monitor the suction control chamber for the water level and the amount of bubbling. The
amount of negative pressure transmitted to the pleural space is determined by the water
level in this chamber, NOT by the amount of suction set on the suction regulator. Adjust
the suction so that gentle bubbling appears in the chamber.
This material is copyrighted by RC Educational Consulting Services, Inc. Unauthorized duplication is prohibited by law.
15
suction pressure to support the device. The Pleur-evac neonatal chest drainage unit is one
such device.
CONTINUOUS MONITORING
Heart rate
Pulse pressure
Transcutaneous oxygen
Transcutaneous CO2
MANAGEMENT
PREVENTION
Fibrin glue has been used in neonates to seal cannulation sites in ECMO and to seal
postoperative thoracic duct leaks. Fibrin glue is made of fibrinogen and factor XIII combined
with thrombin and calcium forming a coagulum. It stimulates the formation of a fibrin clot
within second after administration. In a recent study, infants with persistent pneumothorax had
fibrin glue inserted into their pleural air pocket. The chest tube(s) was briefly clamped.
The study concluded that this form of treatment was effective for infants unresponsive to
standard therapy for persistent pneumothorax.
This material is copyrighted by RC Educational Consulting Services, Inc. Unauthorized duplication is prohibited by law.
16
Observation:
Central and peripheral cyanosis
HR 80 and decreasing
SpO2 68% on FIO 2 of .48
Ventilator parameters were not changed
Rate 35BPM
PIP 22 cmH 2 O
PEEP 4 cmH2 O
IT 0.4 sec
Quick examination of the ventilator circuit reveals no obvious disconnection or occlusion.
Chest excursion greatly diminished bilaterally
Breath sounds decreased on the right side
Heart sounds muffled
PMI shifted slightly left
This material is copyrighted by RC Educational Consulting Services, Inc. Unauthorized duplication is prohibited by law.
17
Transillumination shows a large atypical light reflection on the right superior thoracic area.
This material is copyrighted by RC Educational Consulting Services, Inc. Unauthorized duplication is prohibited by law.
18
This material is copyrighted by RC Educational Consulting Services, Inc. Unauthorized duplication is prohibited by law.
19
SUMMARY
A tension pneumothorax is a life-threatening condition caused by air trapped within the pleural
space that is under pressure thereby displacing the mediastinal structures and compromising
cardiopulmonary function. A tension pneumothorax in the neonate is generally due to the
rupture of alveoli due to uneven aeration. Infants who have been manually resuscitated, those
who have respiratory distress syndrome (RDS), meconium aspiration syndrome (MAS),
pneumonia or those who are have been intubated or are being mechanically ventilated have the
highest incidence of pneumothorax. Aggressive suctioning techniques have been known to
cause tension pneumothorax in the neonate. A pneumothorax causes increased intrathoracic
pressure that, in turn, causes a sudden rise in cerebral capillary pressure that may lead to cerebral
hemorrhage.
The physical signs and symptoms of pneumothorax are fairly remarkable. Generally, especially
in those infants receiving mechanical ventilation, there is a profound and rapid cardiopulmonary
deterioration. The infants vital signs become abnormal; signs of severe respiratory distress are
displayed. Asymmetric chest excursion may be observed. The infant may not respond to
resuscitative efforts. Movement of the point of maximal impulse (PMI) may occur. A positive
pulsus paradoxus is of concern. Distended neck veins may be noted in the infant. Careful
monitoring and assessment of those infants at perceived highest risk is vitally important.
The chest X-ray is an acceptable means of obtaining a definitive diagnosis of pneumothorax.
Transillumination, visualizing the chest wall with a high-intensity fiber optic light source, is
often the quickest diagnostic tool available to the bedside practitioner and may be used in routine
monitoring of the high-risk neonate. The location of the pneumothorax is easily seen on chest Xray as a black area without lung markings. The two most unreliable assessment tools used to
diagnose tension pneumothorax in the neonate are palpation of a deviated trachea and breath
sounds.
Treatment of tension pneumothorax is focused on management and monitoring. Monitoring
pulse pressures, heart rate, arterial blood pressure and location of PMI is highly suggested in the
care of the infant at high risk for developing an air leak. The emergent treatment for a tension
pneumothorax is to, of course, support the cardiopulmonary system, but needle decompression or
chest tube insertion must be done to prevent death. Infants with persistent pneumothorax
unresponsive to conventional treatment may be treated successfully by the administration of
fibrin glue.
This material is copyrighted by RC Educational Consulting Services, Inc. Unauthorized duplication is prohibited by law.
20
This material is copyrighted by RC Educational Consulting Services, Inc. Unauthorized duplication is prohibited by law.
21
V, VI, III, II
I, II, IV, V
I, II, III, V
I, II & III only
2. Transillumination:
I.
II.
III.
IV.
II, III, IV
I, II, III
I, III, IV
I, II, IV
This material is copyrighted by RC Educational Consulting Services, Inc. Unauthorized duplication is prohibited by law.
22
5. A tension pneumothorax can lead to cerebral hemorrhage in the infant due to:
a. Increased intrathoracic pressures and subsequent sudden rise in cerebral capillary
pressure.
b. Decreased pulmonary compliance
c. Bradycardia and tachypnea
d. Hypoxemia
6. Causes of tension pneumothorax include:
I.
II.
III.
IV.
V.
I, II, III, IV
II, III, IV, V
I, III, IV, V
III, IV, V
I, III, IV
I, II, III
II, III, IV
I & IV only
This material is copyrighted by RC Educational Consulting Services, Inc. Unauthorized duplication is prohibited by law.
23
I, II, III, IV
All of the above
I, II, III, V
I, II, IV, V
10. The PALS recommendation for a needle catheter placement in needle decompression of a
tension pneumothorax is:
a.
b.
c.
d.
12. The two most unreliable assessment tools for the diagnosis of tension pneumothorax are:
a.
b.
c.
d.
This material is copyrighted by RC Educational Consulting Services, Inc. Unauthorized duplication is prohibited by law.
24
13. An infant at risk for the development of air leaks should have the following continuously
monitored:
I.
II.
III.
IV.
V.
pulse pressures
heart rate
arterial blood pressure
transcutaneous O2 and CO2
location of PMI
a.
b.
c.
d.
I, II, III, IV
I, II, III, V
I & II only
All of the above
I, II, III
II, III, IV
I, IV, II
I, II, III, IV
15. The following refers to the proper needle decompression procedure in the perinatal/pediatric
patient:
a. 25 gauge over the needle catheter through the 4th intercostal space at the midaxillary
line
b. 14 gauge over the needle catheter through the 2nd intercostal space at the
midclavicular line
c. 23 gauge over the needle catheter through the 3rd intercostal space in the anterior
axillary line
d. 18 gauge over the needle catheter through the 5th intercostal space at the
midclavicular line
This material is copyrighted by RC Educational Consulting Services, Inc. Unauthorized duplication is prohibited by law.
25
a b c d
2.
a b c d
3.
a b c d
4.
a b c d
5.
a b c d
6.
a b c d
7.
a b c d
8.
a b c d
9.
a b c d
10. a b c d
11. a b c d
12. a b c d
13. a b c d
14. a b c d
15. a b c d
This material is copyrighted by RC Educational Consulting Services, Inc. Unauthorized duplication is prohibited by law.
26
NAME:____________________________________________ DATE:______________
AARC # (if applic.)________________________ STATE LICENSE #:______________
RC Educational Consulting Services, Inc. wishes to provide our clients with the highest quality
CE materials possible. Your honest feedback helps us to continually improve our courses and
meet CE regulations in many states. Please complete this form and return/submit it with your
answer sheet. Thank you.
YES
NO
Were the objectives of the course met?
Was the material clear and understandable?
Was the material well-organized?
Was the material relevant to your job?
Did you learn something new?
Was the material interesting?
Were the illustrations, if any, helpful?
Would you recommend this course to a friend?
What was the most valuable portion of the material?
________________________________________________________________________
What was the least valuable portion of the material?
________________________________________________________________________
Suggestions for future courses: ______________________________________________
Comments: ______________________________________________________________
________________________________________________________________________
What is your specialty area?______________________________ Credentials?________
How did you hear about RCECS?____________________________________________
This material is copyrighted by RC Educational Consulting Services, Inc. Unauthorized duplication is prohibited by law.
27