The document describes the steps taken to edit a portrait photo by creating a layer mask, filling in the background around the subject using brushes, and adding additional background images to create a double exposure effect. Background images were overlaid at low opacities and tools like the eraser and gradient were used to blend the elements together.
The document describes the steps taken to edit a portrait photo by creating a layer mask, filling in the background around the subject using brushes, and adding additional background images to create a double exposure effect. Background images were overlaid at low opacities and tools like the eraser and gradient were used to blend the elements together.
The document describes the steps taken to edit a portrait photo by creating a layer mask, filling in the background around the subject using brushes, and adding additional background images to create a double exposure effect. Background images were overlaid at low opacities and tools like the eraser and gradient were used to blend the elements together.
around the subject with a large brush, but being careful not to go too close to the subject herself.
To fill in closely around the subject, I
used a very small brush (1-4px) to ensure that it was correctly filled in.
When editing around the hair, I
had to use a one pixel brush to give a realistic effect.
After I filled in the
entire background, the image looked like this.
By holding alt and clicking on
the layer mask, I was able to see the layer mask on its own. As I was going to be adding things to the background later on, I filled in the white bits on the sides that had not previously been well covered with the same brush.
I then added the image to
Photoshop that I wanted to create the double exposure effect with behind the subject.
I then I held alt and when
hovering the cursor over the subject picture icon, so that I could create a clipping mask. This meant that the background would be behind the subject. I also changed the opacity of the background to position it where I wanted it.
Next, I used the eraser tool
with a medium opacity to blend the background image to the subject.
I then went on the gradient
tool and added a smoky tone to the portrait image to make the final image more effective and similar to the True Detective introduction.
By using the saturation tool, I
selected a dull, brown colour and changed the colour of my background.
After, I added another image
to the very background. I dragged the icon so that it was above the background and then changed to opacity to 8%.
Finally, I added another image
to the background and also changed its opacity to 8%.