5. When you adjust thermostatic expansion valve
1. Refrigerant must be bled off the sensing line before adjustments are made
2. All refrigerant must be pumped into the receiver before adjustments are made
3. Time must be allowed for conditions to stabilize in the evaporator before further adjustments are made
4. All refrigerant must be routed through the dehydrator while changing the superheat setting
ANS C
5. The cylinder unloading mechanism used on low pressure air compressors is an example of which mode control?
1. Two positions
2. Derivative
3. Integral
4. Single speed floating
5. Which of the following is the primary operational difference between a huddling chamber safety valve and a nozzle reaction safety valve?
1. Adjustment of lifting pressure
2. Valve relieving capacities
3. Principle in accomplishing blow down
4. Initial valve opening cause by steam pressurejj
5. When you adjust thermostatic expansion valve
1. Refrigerant must be bled off the sensing line before adjustments are made
2. All refrigerant must be pumped into the receiver before adjustments are made
3. Time must be allowed for conditions to stabilize in the evaporator before further adjustments are made
4. All refrigerant must be routed through the dehydrator while changing the superheat setting
ANS C
5. The cylinder unloading mechanism used on low pressure air compressors is an example of which mode control?
1. Two positions
2. Derivative
3. Integral
4. Single speed floating
5. Which of the following is the primary operational difference between a huddling chamber safety valve and a nozzle reaction safety valve?
1. Adjustment of lifting pressure
2. Valve relieving capacities
3. Principle in accomplishing blow down
4. Initial valve opening cause by steam pressurejj
5. When you adjust thermostatic expansion valve
1. Refrigerant must be bled off the sensing line before adjustments are made
2. All refrigerant must be pumped into the receiver before adjustments are made
3. Time must be allowed for conditions to stabilize in the evaporator before further adjustments are made
4. All refrigerant must be routed through the dehydrator while changing the superheat setting
ANS C
5. The cylinder unloading mechanism used on low pressure air compressors is an example of which mode control?
1. Two positions
2. Derivative
3. Integral
4. Single speed floating
5. Which of the following is the primary operational difference between a huddling chamber safety valve and a nozzle reaction safety valve?
1. Adjustment of lifting pressure
2. Valve relieving capacities
3. Principle in accomplishing blow down
4. Initial valve opening cause by steam pressurejj
Is there any tell tale hole provided in plate type heat exchanger.
Ans. Yes ref mac George page no 7.
Ses chest is cleaned n found that filter is stainless steel bucket type inside which there is zinc anode .the purpose of the anode is------- and should be electrically------- with the filter body. a) stainless steel filter, isolated b) protect adjacent pipeline s, continuous answer