The document provides instructions for removing the top cover and replacing fuses on a Perfect Wave Transport Service unit. To remove the top cover, place a decal over the unit, remove 4 screws, tip the unit on its side, and push the top off using a small screwdriver in the screw holes. To replace the fuses, lift off the fuse cover and fuse and replace it with a 5x20mm, 1amp slow blow, 250V fuse.
The document provides instructions for removing the top cover and replacing fuses on a Perfect Wave Transport Service unit. To remove the top cover, place a decal over the unit, remove 4 screws, tip the unit on its side, and push the top off using a small screwdriver in the screw holes. To replace the fuses, lift off the fuse cover and fuse and replace it with a 5x20mm, 1amp slow blow, 250V fuse.
The document provides instructions for removing the top cover and replacing fuses on a Perfect Wave Transport Service unit. To remove the top cover, place a decal over the unit, remove 4 screws, tip the unit on its side, and push the top off using a small screwdriver in the screw holes. To replace the fuses, lift off the fuse cover and fuse and replace it with a 5x20mm, 1amp slow blow, 250V fuse.
1. Place the clear plastic decal cover over the units top to prevent scratches. 2. On a flat, clean, and soft work space, with a #1 Philips screw driver, remove the 4 #4-40 flat head screws (circles) shown below left. 3. Referencing the back of the unit, tip the unit on its left side with the AC inlet module nearest the work surface as shown below right. 4. With a small screw driver push the top off by pushing the screw driver through the 4 holes on the bottom that the screws were just removed from. Try and push equal amounts on each hole to slide the top out uniformly. 5. Once the top has been pushed out enough it will fall to the left as shown below. 6. Disconnect the ground wire from the distribution block with a pair of pliers.
Replacing the Fuses:
1. To change the fuses on the power supply board, lift off the fuse cover with the fuse. 2. Replace with a 5x20mm, 1amp slow blow, 250V fuse. Schurter part number 0034.3117 or equivalent.
4826 Sterling Drive, Boulder, CO 80301 PH: 720.406.8946 FX: 720.406.8967