Professional Documents
Culture Documents
Table 400
Table 400
1-2007
IEEE Guide for Field Testing of Laminated Dielectric, Shielded Power Cable Systems Rated 5 kV and Above
with High Direct Current Voltage
Table 1 Field test voltages for shielded power cables from 5 kV to 500 kV system voltage
System voltage,
kV rms,
phase-to-phase
Acceptance test,
kV dc,
phase-to-ground
System BIL,
kV crest
Maintenance test,
kV dc,
phase-to-ground
75
28
23
95
36
29
15
110
56
46
25
150
75
61
28
170
85
68
35
200
100
75
46
250
125
95
69
350
175
130
115
450
225
170
115
550
275
205
138
650
325
245
161
750
375
280
230
1050
525
395
345
1175
585
440
345
1300
650
488
500
1425
710
535
500
1550
775
580
500
1675
838
629
NOTE 1Voltages higher than those listed, up to 80% of system BIL, may be considered, but the age and operating
environment of the system should be taken into account. The user is urged to consult the suppliers of the cable and
any/all accessories before applying the high voltage.
NOTE 2When older cables or other types/classes of cables or other equipment, such as transformers, switchgear,
motors, etc. are connected to the cable to be tested, voltages lower than those shown in this table may be necessary
to comply with the limitations imposed by such interconnected cables and equipment. See IEEE Std 95 [B5]7 and
Table 1 of IEEE Std C37.20.2-1999 [B7].
NOTE 3If the test voltage exceeds 50% of system BIL, surge protection against excessive overvoltages induced
by flashovers at the termination should be provided.
NOTE 4It is strongly recommended that the user consult with the manufacturer(s) of all components that will be
subjected to such testing before performing any tests on cables and cable accessories rated 115 kV and higher.
NOTE 5It should be noted that this table and the test procedures suggested in this guide do not necessarily agree
with the recommendations of other organizations, such as those of the Association of Edison Illuminating
Companies [B1], [B2], [B3], [B4]. Where there is concern, a user should consult the supplier of the cable and
accessories to ascertain that the components will withstand the test.
7
Copyright 2007 IEEE. All rights reserved.
Authorized licensed use limited to: Wuhan University. Downloaded on November 8, 2008 at 14:30 from IEEE Xplore. Restrictions apply.