Professional Documents
Culture Documents
Ubiquiti Config
Ubiquiti Config
Hardware Installation
1. Initial placement for programming and configuration purposes should be performed
in an indoor environment. This will facilitate the link setup procedure.
2. After configuration, place the unit in an appropriate place using the mounting kit.
3. Run the Ethernet cable outdoors and plug it into the PoE injector port labeled
POE.
4. Plug one end of another Ethernet cable into your PC/Notebook and the other end
into the PoE injector port labeled LAN.
5. Insert the DC-inlet of the power adapter into the PoE injector port labeled DC,
and the other end into the wall outlet.
IP Address Configuration
This device can be configured as a Station or Access Point. The default IP address of
the device is 192.168.1.20. In order to log into this device, you must first configure the
TCP/IP settings of your PC/Laptop.
For Windows XP users:
1. In the control panel, double click Network Connections and then double click on
the connection of your Network Interface following screen.
2. Select Internet Protocol (TCP/IP) and then click on the Properties button. This
will allow you to configure the TCP/IP settings of your PC/Notebook.
3. Select Use the following IP Address button and then enter the IP address and
subnet mask. Ensure that the IP address and subnet mask are on the same
subnet as the device.
For Example:
Device IP address: 192.168.1.20
PC IP address: 192.168.1.70
PC and Device subnet mask: 255.255.255.0
4. Click on the OK button to close this window, and once again to close LAN
properties window.
HD Communications Corp.
2180 Fifth Avenue, Ronkonkoma, NY 11779
Tel: (631) 588-3877 Fax: (631) 588-3879 E-mail: techs@hdcom.com Web: www.hdwifi.com
HD Communications Corp.
2180 Fifth Avenue, Ronkonkoma, NY 11779
Tel: (631) 588-3877 Fax: (631) 588-3879 E-mail: techs@hdcom.com Web: www.hdwifi.com
Note: The SSID must match in both the Access Point, as well as the Station. It is not
necessary to enter an SSID in the Station/Client unit if you choose the Scan button
located next to the SSID field in the Station Mode unit only.
FIRMWARE UPGRADES
It is recommended that you install the most current and up to date firmware revision for
the specific Ubiquiti model that you are using (i.e. PS2, PS5, NS2, NS5, etc.). You can
find the firmware you need by going to the manufacturers website:
http://www.ubnt.com/support/
Contact Ubiquiti Support:
Ubiquiti support engineers are located in the U.S. and in Europe and are dedicated to
helping customers resolve software, hardware compatibility, or field issues as quickly as
possible. We strive to respond to support inquiries within a 24-hour period.
Email:
support@ubnt.com
Phone:
408-942-1153 (9am-5pm PST)
Ubiquiti Support Forum - You will find a wealth of information from both the Ubiquiti
Networks support engineers and the WISP communities. The forum is a great place to
find information.
http://forum.ubnt.com/forum/
HD Communications Corp.
2180 Fifth Avenue, Ronkonkoma, NY 11779
Tel: (631) 588-3877 Fax: (631) 588-3879 E-mail: techs@hdcom.com Web: www.hdwifi.com