Professional Documents
Culture Documents
How To Set Up The Wireless
How To Set Up The Wireless
Fig. 1
Fig. 2
Mode of setup
- WEP-64Bits > type 5-character code (from 0 9, a, b, c, d, e, f)
- WEP-128Bits > type 13- character code (from 0 9, a, b, c, d, e, f)
Fig. 3
Mode of setup
- WPAPSK , WPA2PSK , WPAPSKWPA2PSK > type 8 63- character code
Click Interface Setup > Wireless > go to SSID Settings > select Yes at WPS to
activate WPS (the default is No) > there are 2 modes to choose at WPS Settings
PIN Code > Start WPS (if Start WPS is clicked the pop up as shown in fig.6 appears)
AP Self PIN Code must be entered to use the SSID
PBC > click Start WPS (if Start WPS is clicked the pop up as shown in fig.6 appears)
the device connected to the SSID starts working
A message to connect the WPS pops up (must be connected within 2 minutes) then
click OK