A simple discrete-time differentiator is defined by the difference equation
yenT)=1/Tx(nT)-x(nT-T)]
Determine the amplitude and phase responses of the discrete-time differentiator. Plot the amplitude
and phase responses as functions of normalized frequency of r=fifs. Compare these responses.
with the amplitude and phase responses of an ideal differentiator.
‘A description of a 74194 4-bit bidirectional shift register follows. The CLR input is asynchronous
and active low and overrides all the other control inputs. All other state changes occur following the
rising edge of the clock. if the control inputs $1=S0=1, the register is loaded in parallel. S1=1 and,
80-0, the register is shifted and SOR(serial data right) is shifted into Q3. f $1=0 and $0=1, the
register shifted left and SDL s shifted into QO. If $1=S0=0, no action occurs.
tH
(@). Write a behavioral-level Verilog model for the 74194,
(b). Drew a block diagram and write a Verilog description of an 8-it bidirectional shift register that
ses 741845 as components. The patalledl inputs and outputs to the 8-bit register should be
X({7-0)) and ¥((7 0)). The serial mputs should be RSD and LSD.Problem 1
a - Plot the Fourier transform X(w) of the discrete-time s
and HW2-1-b, for w € [—27, 27]. Make sure you specify 1]
points of your graph in terms of x (“critical points” mea
of impulse functions, or the frequency value of the points
Make sure also to represent the amplitude values of your
b - Input the signal ,(t) of HW2-1-b into the system sh
in HW2.
| x/n/] yin]
0 —| sampling |} ln) faa
digital
filter
We assume that the digital filter ha[n] has a Fourier tran
4 YO)
Give the value of a, the maximum value of w, and the
nanl Mm £ AY Dinlate conte anaecneAA digital fitter has the unit pulse response h(aT)=[0,1,2.2.1,0.~
[1.1,2,2,1,0,-1,-1,0,0.0). Find the output
10,0) and input xin}:
Please show all work!
(Consider a LT! system with transfer function (6) = —25+10_
37420410
following inputs, find the zero-state response of the system in each ease. Verify
‘your results using MATLAB (Hint: Use polyval function and include your code).
Given the
a) x(@)-e"
Suppose that we have two coaxial metal cylindrical tubes (see the figure below), each
carrying charges +Q. Is there a voltage difference between these two tubes? What
happens when we connect them using a thin wire? (Hint: Calculate the electric field
between the two tubes, and then use if to derive the voltage.)
2. Two tiny dots A and B both have charge +q are placed at (x,y)=(1.1) and (1,1).
Where can we place a third dot of charge +q to make the electric field vanish at the
origin? What if B has charge -q instead?Explain why Digital Predistortion (DPD) has great potential for application not anly in phased array
radar systems utilizing wideband coded waveforms, but also in modem and emerging radar
systams that can utilize non-constant modulus waveforms with broad instantaneous bandwidth,
such as MIMO radar systems, SAR systems utilizing wideband beamforming, ete