CT scanning works by sending X-rays through a part as it rotates, with a detector collecting thousands of 2D images to reconstruct a 3D image. This 3D image can be filtered to view specific internal areas and components by material density, and can be used for finite element analysis or to verify manufacturing against CAD models.
CT scanning works by sending X-rays through a part as it rotates, with a detector collecting thousands of 2D images to reconstruct a 3D image. This 3D image can be filtered to view specific internal areas and components by material density, and can be used for finite element analysis or to verify manufacturing against CAD models.
CT scanning works by sending X-rays through a part as it rotates, with a detector collecting thousands of 2D images to reconstruct a 3D image. This 3D image can be filtered to view specific internal areas and components by material density, and can be used for finite element analysis or to verify manufacturing against CAD models.
To begin an X-ray source sends radiation through your part.
The 3D image of your part can then be filtered by
material density to view specific areas and internal parts of your assembly. This scan can also be used for Finite Element Analysis (FEA) of a manufactured part as well as comparison to CAD to verify manufacturing.
An image of your part is collected by the detector screen.
Your part is mounted
on a work table capable of infinite rotation.
While your part is rotated through a full
360 degrees, thousands of 2D images are collected. The data is then reconstructed to combine all of the 2D images, creating a 3D image of your part.
In this example you can see the real
lightbulb and the reconstructed scan of the lightbulb. The last image is the lower density case of the lightbulb removed, leaving only the internal (higher density) components for viewing.