Professional Documents
Culture Documents
Electronics For 3D Printer: Muhammad Danial Hassan
Electronics For 3D Printer: Muhammad Danial Hassan
PRINTER
Muhammad Danial Hassan
1. Microcontroller
2. Peripherals
3. Stepper Drivers
4. Wiring
5. Future Plans
Microcontroller
Initial plan is to use to Arduino Mega, however after
further discussion using Megatronics is much better.
Megatronics use Arduino IDE software for coding.
Advantages:
i.
ii.
iii.
iv.
STEPPER DRIVERS
Currently using the A4988 stepper driver (with heatsink)
to drive the motors.
Current and step resolutions (up to 1/16-step) can be
adjusted.
Other alternatives; DRV8825 (finer steps, up to 1/32step).
WIRING
FUTURE PLANS
Complete the wiring of all the components (motor,
endstops) onto the Megatronics.
Consult with electrician about the safety of the
connection.
Test the movement of the printer.