You are on page 1of 2

Topology:

For quick note about topology : Datacenter1, datacenter2, Headquarter, Branch office, large office, small
office, home office , isp 1 and isp 2 for internet service, 1 global isp 1 local isp for MPLS connectivity .
Access enable on everything, except, local ISP, both internet ISP (grey out).

Protocol asked in New TS: hsrp, port-channel , OSPF and ospfv3, bgp (very highly used) 1 DMVPN with 2 spoke
with ospf (in datacenter-1), 1 DMVPM with 1 spoke (in datacenter-2), MPLS. Eigrp not found.
Total 10 questions. Unable to solve any.

1. user in large office unable to access R40, to verify match the given trace and sh standby status. Trace
output give to match.
Found no ip on user, switch connected with user configure with L2 port channel with 2 upper switches
configure with hsrp, both are active. 2 point.

2. user from datacenter 1 unable to access 8.8.8.8 from internet isp 1. Trace output given to match. 2 point.

3. traffic engineering. Vlans are not load balancing between datacenter 1 and datacenter 2. trace output given
to match. 4 point . found vlan access-list.
4. Branch office unable to access datacenter with the required path. trace output given to match. 2 point.
5. In branch office, Bgp connectivity failed with global service provider (mpls). 2 point.

6. user in datacenter 1 unable to access ipv6 address from ISP. trace are given to match. 2 point.

7. OSPF route are not received in small office from datacenter 1. required sh ip ro ospf output given. 4 point.
small office is configure as DMVPN spoke , hub in datacenter 1. I found DMVPN was struck in ext stat, i
configure ip ospf network broadcast on hub and spoke. after that ospf neighbor-ship is up, but still no route
received.
8. user in headquarter unable to access server in datacenter 1. Trace output give to match. 2 point.

I found no ip on user, switch connected to user was configure with port channel. two upper switch was
configure with hsrp, which seems working fine to me. but issue still persist.

9. Home office user unable to access server in datacenter 2. DMVPN connectivity, between them. trace given
to match output 2 point.
10. nas server unable to telnet in datacenter 2. trace output given to match. 2 point.

You might also like