Professional Documents
Culture Documents
column): 8
Enter the yield stress of steel in MPa: 250
Enter the degree of end restraint of the compression member
For effectively held in position
1.and restrained against rotation at both ends
2.at both ends and restrained agains rotaion at one end
3.at both ends restrained against rotation at one end
4.and restrained against rotation at one end, and at the other hand restrained a
gainst rotation but not held in position
5.and restrained against rotation at one end, and at the other hand partially re
strained against rotation but not held in position
6.at one end but not restrained against rotation, and at the other hand restrain
ed against rotation at held in position
7.and restrained against rotation at one end but not held in position or restrai
ned against rotation at the other hand: 2
Enter the permissible compressive stress of the steel in MPa: 120
The area required for given loading is 10000mm2
Enter which type of section to be provided
1.Two Channel Section
2.Two I Section
3.Four Angle Section: 1
Enter which channel (IS) section is to be provided (ISJC, ISLC, ISMC, ISMCP)ISLC
Enter th depth of the ISLC section so as to meet the requirements: 350
Enter the area of single ISLC 350 section in mm2: 4954
Enter the radius of gyration about X-X axis for the given ISLC 350 in mm: 137.2
Enter the permissible stress for steel for slenderness ratio 51.387 from IS 800:
------------------------------------------------------------------------------------DESIGN OF BATENS
Spacing of Battened bars in mm
100
300
300X6.8mm