In
Maidal HS-VK5Jr (=
BASE STATION 4
3.5/7/14/21/28Miz jen |
HF S-BAND GROUND PLANE ANTENNA
aoe INSTRUCTION MANUALS 2txcoKmn
FEATURES
1) Compact ground plane antenna for Hr Sbands - 3,5/7/14/21/28tHe.
2) tow loss traps, with newly designed coil bobbin, accept operation of -
500W/SSB. |
3) angles of radials are adjustable, You can fix them to ami-directional
or to one-side, when mounting to narrow space.
4) Hasy frequency adjustwent, changing length of elements, and
intervals between each traps.
SPECIFICATIONS
Type... +++ 5-Band Ground plane
s++ 3.5/7/14/21/28MEiz.
-+-‘Less than 1.5 (at the center frequency)
--- 509
SO0W(SSB) , 250W(C¥), 120w(Continously}
‘But, the followings are available for only 3.5MHz.
200W (SSB), LOOW( CW) ,SOW(Continously)
Max.Wind speed. . 35m/sec. (80MPH) (Instantaneans)
Mast Diameter... 308 — 624
i S0-239
2,000m/m (80in.)
6,100m/m (20.3£t.)
6.0 kgs.
bs
asi - 19 center take
rete = toute + tou
tate - oar Frequency 4 rate
fete = tsa + serie
nai Toole 1 rome
NOTES:
1) Before assembling, check the numbers of parts, according to the Parts List.
2) Always use high quality coax. cable of 50 ohm, end connectors.
3) Be sure the connector is properly secured and water-procfed by using
adhesive vinyl take.
4) Install antenna so that no other antenna tor metallic cbjects are closer.
than 2meters, to avoid eny. possible influences from them,
5) Please refrain from transmitting with power levels greater than the
specified,ADUSTPENT
Adjastment should be done by using a VSWR Meter
with proper capacity, frequency range and impedance.
Transmitting for adjustment should be carried cut
in a short time with a lower power of ander SOW to
avoid a possible disturbance to others.
SGI
Cable
(1) Table (A) shows the standard radial length
and the center frequency change per lem
adjustment of the radiais,
TABLE AL
Standard Length | Center frequency
(a/a)| change per 10/3
ect |Ghe"Side | Radialsadjostacat,
Tope |
can EEPEREE | — osetencatce)
a sstece tings)
26 tes noieisil
| straytay
26 Hex,note(S} | Jo, gat Ring)
Tedjuaravte EASE 33 uae Bene
vate For mas” (17!
na he
arent)” [Ste ace
xsi [eos 6 te aay 06 Trae ta
| Miz} 1250_} 15, Tie TO yajanesie
Mie 27011306. 18” Ki ee for tame
a iia | Tie0” [2180 28 Ki ei |
28 wi | iis0. 50 Kir Nye Lock Ring(4)
=
T
(2) Set your transceiver On at a desired band jele[—O7 Traptc)
and confirm the center frequency. apse
The adjustment should be done from the WS tor thats
highest band (28MHz) to the lower one.
(3) According to the TABLE A, adjust the length
of the radials to get @ desired frequency.
When you fix the-radials longer, the center
frequency becomes lower.
Conversely, when the radials shortened, the
center frequency becoves higher.
(4) When the V.SWR of center frequency is not sufficiently
ow enough, further tunig can be done by adjusting the
length of vertical Rediator Elements.
Freguency change per each 10m/m is just save as TABLE A.
You can find each adjustable Spaces at below each ‘Traps
and Element(A)(o2).
(5)
of each Screws.
After elements adjustment, kindly confirm tight fastening
Nt
yr ogtrap iD)
eb 7 S2Hae Rine(2)
cranes Eee
leon 280s 7 ae
fas VN ine
porenenels) 2) 34 doxomele
I~ 04 Element (C)
DIAGRAM EASSENBLY (Refer to DIAGRAM B)
1) Attach Mount Pipe(20) to your mast. There
should be at least 150n/m interval between
the. top of the mest and the top of-the macching AA) snsutavor
Mount Pipe. Seceioe
2} Pass your coax. w/connector through the
Mount Pipe.
3) Attach the waterproof coax. w/connector
to Matching Section (10).
Firmly fasten.each Set Screws by Hex.
wrench.
4) Attach the Insulator to the Matching
Section, with Hex Bolts (29).
5) Using Lock Ring (35) and Hex Bolt-S(26),
insert Radial Elements(16)- into each
Radial units, Refer. to TABLE A for elements
length. 28MHz Coil is shortest, while,
= Connector Cable
3.5¥Hz is longest. mas | Hewnt Pie
6) Refer to DIAGRIM C for setting the radials Speinn washer (1)
angle, omni or one side. ‘ Rese wat (2
‘Then, attach each-Radial units with Hex Nut(25).
‘The Drain Holés of. the radial umits are to be
faced downward.
Hex. Boht (1)
exe wae, ON)
DIAGRAM B
| sian Base (1): 3.5/7HME
sedi Bite Gh) Liei/ome
sm
a“ insulator of
the hatohine
5 patter (Lm Sestion
Base a) FT
oe
fic Bite
(one-Side, sem
(Radials a 30°)
{Omni-~Directional)
Uadials ae 72°)
nadiat
ASSABLY CF VERTICAL ELEMENT fockag downward
{1) Connect the Element(A)(No.2) and the
Element(B}(No.3) by the Star Washer(M4)(No.30)
and Tapping Screw(M4x6)(No.19). Fix the Yat Ring(1)(No.32)
to the Tzap{A)(No.5) at intervals of 10m/mm(1/2inch) and
install the Hat Element(1)(No.33). Also install the Hat Ring(2)(No.32) and
Hat Element{2}(No.34) to the Trap(D){No.8).
(2) Connect. each Trap(A-b) by the Lock Ring and Hex Bolts. Adjust each length
according to the DIAGRAM-E.
(3) Inser the assembled Radiator to. the Matching Section and fix them by the
Hex. Bolts(S](No.26) and the Spring Washer{5)(No-39).
(4) I you plan to install the antenna in a high wind area, the use of guy-line
‘is recommended. Close nylon or other non-metallic guy-line, at point (A) & (B)-PARTS LIST — Drop cap (5)
(Nos.| Pacts Name Oty Remacks 5
OL Tap tan (5) i Toexrsnd ay Tapeing G Tlement (A)
Oz | Beweat 4) 1 T0sx750 7) 3 ret
OE Eleweat {3} i SOSxi4d q ety
A Element (1) i eI
aS. Trap _ 4a) i @ Stor tasker @eteaent (3)
8) tae x
ory ese) i BD lock RAEI TS tien, dole!
ot tan 0 1 [ Qiiex. Bolz(S)
De ‘Top Cap
FCO katching Section 1 NY orree
{1 ealial_@ t 3 SMNe tex. sop. Zo Semen
12 Sadial “(BY 3. TMA Zz BE Ra
ks wadial (C) I i4MHz Gast Ring (1)
if alia _G) i Zima z ee
[S| Wadia Ey 1 2oMH z Brock Rinetn) @iex, Bott (oy
15 ‘Badial Elesent_ 3S 9. 5éx1370
iT Radial Base (1) i w/2-ha le 5 | —- } Trap (8)
rz adial Base (2) 1 w/S-ho les)
19 Tapping screw + 2 M4 x $— r
20 Mount pipe i 32ex 450 fae i
21 Mount bracket 2 @ Lock Ring ‘N fp tex. Bole (4)
22 U-bolt_ 2 MS
ra Tex. fut(S) 6. MS —~- Brrap (c)
fa | er Wath & ME
25 tes te [_s ie (0B,
25, Hex. bol tS) Tz ax @ Lock Ring NO ties a
27 es. bet utt) 4 M6 xi O Hex. gene ow
\2 3 Wes, balt(h)
53 | fet bol UB) 3 MEETS Nore?
1S 0. Star rasher_ 2 M4 ts:
31 dae HD) x 31959 B tox. Bole spat clenent (2)
32 Hat Bing(2y x Tides \ @ Hat Ring (2)
[ss ‘Hat Element. 3 Sox 540 Bex. xut (5)
3A at Siement(2) 3 Sex 500 .
5 beck ting(S) 6 Z2Hxe ‘Brock fing (L>
5 Tock BingCd) 3 23 ax9
T Tock Fing(L) i 33sx9 3
& “Spcing tasker Ey, < M6. _} ‘y
Brot abring Taster(S) 4 Me Dies. note 0
6 19)Mazching
‘Section
r
Getement (6)
OSoring washer (8)
Rada
Graataniad— giiex. sole (5)
p
Biter wat ONES T Gradignicn
— @ragial (a) \ - OF >
ee Goode ning 18)
Fsbiear nhc
DRidiad Base Gitex. poielg type?
Rae Grssiat dase CD
Ja ioe GRadéal (01
Sa 0)
‘ogeional
ost
“St, iter. sone (2)
BH Top Cap ib)
@iadial: Eleaent,
DIAGRAM A