BS EN 10279 : 2000
Hot rolled steel channels
Tolerances on shape, dimension and m:
I n
Section Height
The deviation ftom nominal on section hight (shall
be within the tolerance given in Table 1 for tapered
flange channels and parallel flange channels. Height
is measured over the web ae
Flange Width (b) —
The deviation from nominal on flange wieth (b) shall
bee within the tolerance given in Table 1 for tapered
flange channels and parallel flange channels.
Web Thickness (9)
The deviation from nominal on web thickness (s),
when measured at the mi-height position of the web, 1
shall be within the tolerance given in Table 1 ‘or 1
tapered flange channels and parallel flange channels. t
Flange Thickness (0 nf ttt
The deviation from nominal on flange thickness (0,
when measured ata distance of b72 from the toe of
the lange, shall be within the tolerance given in
Table 1 for tapered flange channels and parallel
flange channels. :
Hel Radius (r)
The radius of the heel radius (7) shall not exceed 0,3¢
where tis the flange thickness
Out of Squareness (k + k) and web bow (f
i. The out of squareness ‘of the section (k +) shall
rot exceed the maximum given in Table 1 for tapered
flange channels and parallel flange channels.
ji, The web flatness (f shall not exceed the
‘maximum given in Table 1 for tapered flange
channels and parallel flange channels. Sanaa
Atenative standard
by agreement
Tass per oi Teng
straightness (qo 4,)
Te saightnes (7, 8 4,) shall conform othe
requirements gen in Table 1 for tapered flange
Channels and parallel flange channels
a Parkers BUY STEEL ONLINE eseN1s0 9001 : 2000
www parkensteel.co-uk