Professional Documents
Culture Documents
Design a network addressing system, with subnet and host IDs including
appropriate devices
Network protocols are the rules that define the standards for communication
between network hosts .Examples of protocols used in computer networking include:
Each computer, network printer or other network host on your organization network
will need a unique IP address – just the same as a letter that is mailed to you through
Australia Post needs a unique address to be delivered to you. These IP addresses can
be either configured manually at each device or assigned automatically by the
network operating system. In this we will look at the format of IP addresses, and how
networks are segregated from each other by using subnet masks. To fully understand
how IP addressing works, firstly you need to be able to translate binary numbers such
as 10001000 to decimal numbers (10001000 =136).
An IP address is 32 bits long and made up of two components, a network portion and
a host portion. The network address is used to identify the network and is common to
all the devices attached to the network. The host (or node) address is used to identify a
particular device attached to the network. The IP address is generally represented
using the dotted-decimal notation, where 32 bits are divided into four octets. Each of
the octets can be represented in a decimal format, separated by decimal points. When
a computer is configured to use the same IP address each time it powers up, this is
known as a Static IP address. In contrast, in situations when the computer's IP address
is assigned automatically, it is known as a Dynamic IP address,The current version of
the IP protocol is IP version 4 (IPv4) & IP version 6 (IPv6).
10101100. 00010000.11111110.00000001
172 16 254 1
Computer 172.16.1.3
hub router hub Computer 172.16.2.3
IP address
Subnet 1 Subnet 2
172.16.1.0/24 172.16.1.0/24
(subnet mask 255.255.255.0) (subnet mask 255.255.255.0)
To internet
NOTE:-Subnet mask - Determine which bits in the host address are the subnet ID
requires using 32 bit value.
----------------------------------------------------------------------------
THE END
------------------------------------------------------------------------------