Professional Documents
Culture Documents
Cisco 640-802
Q&A Demo
www.PassGuide.com
Study Tips
This product will provide you questions and answers carefully compiled and written by our
experts. Try to understand the concepts behind the questions instead of cramming the
questions.
Go through the entire document at least twice so that you make sure that you are not
missing anything.
Latest Version
We are constantly reviewing our products. New material is added and old material is
revised. Free updates are available for 120 days after the purchase. You should check your
member zone at PassGuide an update 3-4 days before the scheduled exam date.
Feedback
If you spot a possible improvement then please let us know. We always interested in
improving product quality.
Feedback should be send to feedback@passguide.com. You should include the following:
Exam number, version, page number, question number, and your login ID.
Our experts will answer your mail promptly.
Copyright
Each pdf file contains a unique serial number associated with your particular name and
contact information for security purposes. So if we find out that a particular pdf file is
being distributed by you, CertBible reserves the right to take legal action against you
according to the International Copyright Laws.
Answer: A,D
Question: 2
What are two characteristics of Telnet? (Choose two.)
Answer: A,E
Question: 3
Refer to the exhibit. Which mask is correct to use for the WAN link between the routers that
will provide connectivity while wasting the least amount of addresses?
A. /23
Answer: D
Question: 4
When a DHCP server is configured, which two IP addresses should never be assignable to
hosts? (Choose two.)
Answer: A,B
Question: 5
Refer to the exhibit. Which WAN protocol is being used?
A. ATM
B. HDLC
C. Frame Relay
D. PPP
Answer: C
Question: 6
Refer to the exhibit. What information can be gathered from the output?
Answer: D
Question: 7
What are three advantages of VLANs? (Choose three.)
Answer: A,E,F
Question: 8
Refer to the exhibit. The network shown in the diagram is experiencing connectivity problems.
Which of the following will correct the problems? (Choose two.)
Answer: B,D
Question: 9
Which statements describe two of the benefits of VLAN Trunking Protocol? (Choose two.)
Answer: D,E
Question: 10
Refer to the exhibit. From RouterA, a network administrator is able to ping the serial interface
of RouterB but unable to ping any of the subnets attached to RouterB. Based on the partial
outputs in the exhibit, what could be the problem?
Answer: D
Question: 11
Select the action that results from executing these commands.
Switch(config-if)# switchport port-security
Switch(config-if)# switchport port-security mac-address sticky
Question: 12
Refer to the exhibit.
A. One
B. Two
C. Three
D. Four
E. Five
F. Six
Answer: C
Question: 13
While troubleshooting a network connectivity problem, a technician observes steady link lights
on both the workstation NIC and the switch port to which the workstation is connected.
However, when the ping command is issued from the workstation, the output message
"Request timed out." is displayed. At which layer of the OSI model does the problem most
likely exist?
Answer: E
Question: 14
Exhibit:
A.
Answer: A
Question: 15
Exhibit:
A.
Answer: A
Question: 16
What are two reasons that a network administrator would use access lists? (Choose two.)
Answer: A, C
Question: 17
A network administrator is designing a new corporate internetwork.The corporation is
concemed about downtime due to link failure and also about link costs. Which topology will
provide some redundancy to increase reliability for all sites but will cost less than a fully
redundant topology?
A.
B.
Answer: B
Question: 18
A network administrator needs to allow only one Telnet connection to a router. For anyone
viewing the configuration and issuing the show run command, the password for Telnet access
should be encrypted. Which set of commands will accomplish this task?
A. service password-encryption
access-list1 permit 192.168.1.0.0.0.0.255
login
password cisco
access-class 1
B. enable password secret
line vty0
login
password cisco
C. service password-encryption
line vty0
login
password cisco
D. service password-encryption
line vty0 4
login
password cisco
Answer: C
Question: 19
Refer to the exhibit:
Answer: A
Question: 20
Acknowledgements, sequencing, and flow control are characteristics of which OSI layer?
A. Layer 2
B. Layer 3
C. Layer 4
D. Layer 5
E. Layer 6
F. Layer 7
Answer: C
Question: 21
Refer to the exhibit. What kind of cable should be used to make each connection that is
identified by the numbers shown?
Answer: E
Question: 22
Why would a network administrator configure port security on a switch?
Question: 23
Refer to the exhibit. When the hosts boot, hosts that are connected to the switches are having
trouble getting a DHCP address from the DHCP server. Which STP feature could minimize
the effects of STP convergence for the hosts?
A. path cost
B. port priority
C. BID
D. PortFast
Answer: D
Question: 24
What is the purpose of assigning an IP address to a switch?
A. To ensure that hosts on the same LAN can communicate with each other.
B. To provide local hosts with a default gateway address
C. To allow the switch to respond to ARP requests between two hosts
D. To allow remote management of the switch.
Answer: D
Question: 25
Refer to the exhibit. A new subnet with 12 hosts has been added to the network. Which
subnet address should this network use to provide enough useable addresses while wasting
the fewest addresses?
A. 192.168.10.80/28
B. 192.168.10.96/28
C. 192.168.10.80/29
D. 192.168.10.96/29
Answer: B
Question: 26
Which one of the following OSPF network types needs to select a BDR?
Answer: E
Question: 27
Refer to the exhibit. This command is executed on 2960Switch:
SW(config)# mac-address-table static 0000.00a
a.aaaa vlan 10 interface fa0/1
Which two of these statements correctly identify results of executing the command? (Choose
two.)
Answer: A,C
Question: 28
Which of the following statements regarding the use of multiple access lists are valid when
configuring a single interface on a Cisco router?
A. One access list may be configured per direction for each Layer 3 protocol configured on an
interface.
B. Application of up to three access lists per protocol to a single interface.
C. The maximum number allowed varies due to RAM availability in the router.
D. No more than two access lists per interface.
Answer: A
Question: 29
Refer to the exhibit. Router1 was just successfully rebooted. Identify the current OSPF router
ID for Router1.
A. 208.149.23.194
B. 208.149.23.162
C. 190.172.32.10
D. 220.173.149.10
Answer: A
Question: 30
The OSPF Hello protocol performs which of the following tasks? (Choose two.)
Answer: E,F