Professional Documents
Culture Documents
8.2. THEORY:
1
8.3 CIRCUIT DIAGRAM
2
f1 f2 f (Hz)
8.6 PROCEDURE:
3
1. Give the connections as per the circuit diagram
4. Using the CRO check the input and output signals & calculate Av
5. Vary the input signal from 100 Hz to 1 Mhz and note down the output
amplitude
6. Measure the input amplitude and calculate the gain and the frequency
9. Measure Vac and Iac I ac at the input and output terminals and calculate
10. Remove the Bootstrap connection and give the conventional voltage
divider bias
11. Measure once again Vac and Iac at the input and output terminals and
bootstrapping
12. Compare the input and output impedance of both the circuits
DC Biasing Voltage
FET Vs Vg Vd Vgs
T1
4
Frequency Output Voltage Gain= 20 log(Vo/Vin)
(in Hz) (in volts) (in dB)
5
Vac Iac Z Vac Iac Z
Input
Output
8.9 RESULT:
Thus, the Source follower with Bootstrapped gate resistance was constructed
and it was found that the input impedance increases with bootstrapping, as given
The frequency response of the Source Follower circuit was evaluated and the
cut-off frequencies and bandwidth obtained are
Bandwidth =
VIVA QUESTIONS
6
3. How does bootstrapping arrangement useful?